Professional Documents
Culture Documents
HYPMANUAL ONLY MONO Updated Compressed
HYPMANUAL ONLY MONO Updated Compressed
HYPNOTIC™ will either repair or replace (as its option) any unit HYP2800D • HYP3600D
that has been found to be defective and under warranty provided the
defect occurs within the one (1) year warranty period.
Instruction Manual
• Installation Instructions / Owners Manual •
Designed and Engineered in the U.S.A.
Due to continuous improvement of the product the Specifications are subject to change without notice.
CONEXION DE BAJO
Model: HYP1200D
INTRODUCTION
Congratulations on your purchase of a state-of-the-art power amplifier. Your selection of a
HYPNOTIC™ car audio product indicates a true appreciation of fine musical reproduction.
Whether adding to an existing system or including your HYPNOTIC™ amplifier in a new system,
you are certain to notice immediate performance benefits.
RECOMMENDATION
A power amplifier’s performance is only as good as its installation. Proper installation will
maximize the system’s overall performance. It is recommended that you have our product
installed by an authorized HYPNOTIC™ retailer. However, if you decide to install it yourself,
please carefully read through this manual and take your time to do a quality installation. Control
Remote
para Bajo
IMPORTANT! Before making any connections, disconnect the car’s battery until the
installation is completed to avoid possible damage to the electrical system.
WARNING!
Exposure to high power sound system can cause hearing loss or
damage. Listening to your system at loud levels while driving will
impair your ability to hear traffic sounds and emergency vehicles.
Use common sense when listening to your system.
1 18
CONEXION DE BOCINAS Y REMOTO SAFETY PRECAUTIONS
Model: HYP1600D, HYP2200D, HYP2800D & HYP3600D
Make all ground wires as short as possible and at the same point
In order to reduce the chance of ground loops (i.e. engine noise), make the grounding wire as
short as possible to reduce the wire’s resistance. Also, when using multiple components, make
sure all units are grounded at the same point.
17 2
FEATURES AND BENEFITS
DC Offset Protection
This circuit protects the output of the amplifier against DC voltage. If for some reason DC voltage is CROSSOVER INTEGRADO
detected at the output stage, the amplifier will shut down protecting the speakers from direct current.
HYP1200D • HYP1600D • HYP2200D
Short Circuit Protection HYP2800D • HYP3600D
The circuit protects the amplifier from damage due to a short found in the speakers or wiring. If one of the
speakers or its wiring comes in contact with ground, the amplifier will shut down. To resume normal
operation, correct the problem and turn the head unit off, then back on. The amplifier will reset and play
again.
Power Fusing
This protects the amplifier against short circuits and excessive current.
Remote Turn-on
Automatically turns amplifier on when connected to the head unit’s remote output. The amplifier will turn
on and off with the head unit to save current consumption. This control also operates the reset circuit for
the amplifier’s protection. It must be connected with the head unit in order to reset protection circuits.
3 16
FUENTE DE ALIMENTACION MONOBLOCK FEATURES:
Es importante que lea este manual y siga las instrucciones con atención: HYP1200D, HYP1600D, HYP2200D, HYP2800D & HYP3600D
Conexión a Tierra.
SPECIFICATION HYP2200D HYP2800D HYP3600D
4. Localice un lugar apropiado para hacer la conexión a tierra que este lo más cerca
posible al amplificador. Asegúrese que la ubicación es un lugar limpio y provea una Power@ 1 OHM Mono 2200 Watts 2800 Watts 3600 Watts
conexión eléctrica directo al chasis de su carro. Conecte un extremo del cable del Power@ 2 OHM Mono 1100 Watts 1400 Watts 1800 Watts
mismo calibre al de poder; en el punto de tierra y el otro extremo al punto de conexión
en el amplificador, el puerto de conexión en el amplificador donde debe conectar tiene la >90dB >90dB >90dB
Signal to Noise Ratio:
identificación: GND. 50 - 220Hz 50 - 220Hz
Low Pass Crossover: 50Hz - 220Hz
Conexión de encendido Remoto. Subsonic Filter: 0- 50Hz 0- 50Hz 0- 50Hz
5. Corra un cable para el encendido remoto desde una fuente de +12V que este acoplada Bass Boost @ 45 Hz: 0-6DB-12DB 0-6DB-12DB 0-6DB-12DB
al funcionamiento de los accesorios del auto. Este punto puede ser uno de los siguien Frequency Response: 10Hz-250Hz 10Hz-250Hz 10Hz-250Hz
tes: un switch, un relé, el cable de encendido de su radio o el cable de encendido de la <0.1% <0.1% <0.1%
THD @ 1 %:
antena eléctrica. Este cable debe ser conectado en la posición REM. Utilice cable 200mV-6V 200mV-6V
Input Sensitivity: 200mV-6V
calibre 16 o un calibre más grueso.
15 4
POWER CONNECTION LEADS CARACTERISTICAS:
HYP1200D, HYP1600D, HYP2200D, HYP2800D & HYP3600D
Conexiones de Poder
Circuito Clase D
Capacidad estable a 1 Ohm [ Modelo: *HYP1200D / 2 Ohm ]
Fuente de Poder con Mosfets Líneas de entrada tipo RCA
Crossover ajustable a12dB para Low Pass Filtro
Subsónico ajustable
Variable Bass Boost @ 45 Hz
Circuito de Protección Térmica
Incluye control Remoto del nivel de Bajo
5 14
CARACTERISTICAS Y BENEFICIOS
Indicador de funcionamiento
Cuando el LED este prendido indica que el amplificador está bien conectado y listo.
Crossover Integrado
Los amplificadores HYPNOTIC™ HYP3400.4 cuentan con crossovers integrados que le permite
hacer ajustes independientes entre los canales frontales y los de atrás de manera independiente.
Remote Bass EQ.
Bloques de distribución para Alimentación y Parlantes
Cuentan con Bloques de Distribución para soportar cables de grueso calibre para un máximo poder
y transferencia de señal con una mínima resistencia.
Líneas de Salida
Líneas de salida de rango completo han sido acopladas para proveer una conexión de
amplificadores adicionales en su sistema, las salidas están preparadas para reducir la perdida de
señal.
Fusible de Protección
Estos protegen al Amplificador de cortos circuitos y de picos de corriente.
13 6
BASS CONECTION & REMOTE CONTROL PRECAUCIONES DE SEGURIDAD
Model: HYP1200D
7 12
BASS CONNECTION & REMOTE CONTROL
INTRODUCCION HYP1600D, HYP2200D, HYP2800D & HYP3600D
RECOMENDACION
El desempeño de su sistema de audio depende de la calidad de su instalación. Una
instalación apropiada optimizara en general el desempeño de su sistema. Le sugerimos
que su producto sea instalado por un Distribuidor Autorizado por HYPNOTIC™. Aun si
usted decide instalarlo por su cuenta, por favor lea este manual con atención y tome el Wired
tiempo necesario para hacer una instalación de calidad. Remote
Control
¡PELIGRO!
Exponerse por tiempo prolongado a altos niveles de sonido y/o ruido, puede causar
daño o pérdida del oído. Usar su sistema con alto volumen mientras va manejando
puede hacer que pierda su habilidad de escuchar problemas de tráfico o vehículos de
emergencia. Use el sentido común mientras utiliza su sistema de audio.
11 8
GARANTIA LIMITADA
Manual de Instrucciones
•Instrucciones de Instalación / Manual del Propietario•
Designed and Engineered in the U.S.A. Debido a la mejora continua de los productos, las Especificaciones están sujetos a cambio sin previo aviso.