EX4414 The C-axis synchronous command is specified
C-AXIS NEED ZERO PER4414 though the C-axis is not returned to the zero RETURN point. EX4415 TURNNING TOOL IS PER4415 Turn set in rotary tool entry screen. SET EX4416 The rotary tool spindle rotation command is POWER LINE NOT PER4416 specified while exchanging of the rotary tool EXCHANGE spindle power line is not completed. EX4550 HYDRAULIC UNIT Please clean the rotation adjustment screw for MER4550 WARNING the hydraulic unit and change the oil. EX4901 The steady rest open/close command is STATION NO. NOT PER4901 specified while the turret station No. does not CORRESPONDED agree. EX4903 The turret index command is specified while the REST NOT CLOSED PER4903 rest is not closed. EX4911 A spindle forward/reverse, rotary tool spindle STEADY REST CLAMP PER4911 forward/reverse command has been given while SIGNAL IS OFF the staedy rest is not clampped EX4916 NO STEADY REST Steady rest open and close detect signals are PER4916 OPEN/CLOSE DETECT both off when cycle start is commanded. EX4917 TOOL DOESN'T TOUCH Tool doesn't touch on the sensor in the presetter PER4917 ON THE SENSOR mode. Change the start position. EX4927 POSITION OF PARTS Setting of parameter for parts catcher middle PER4927 CATCHER INCORRECT position is mistaken. EX4928 PARTS CATCHER IS IN Parts catcher is in interference area at M244 PER4928 INTERFERENCE AREA command. EX4930 NO COORDINATE The manual coodinate setting was done during SETTING DURING PER4930 auto operation. AUTO OP EX4931 It is not possible state by manual coodinate NO MANUAL setting. Please confirm whether it is not during PER4931 COORDINATE SETTING reset, emg, cylindrical and poler coordinate interpolation. EX4935 OL TIP & DIRECTION A start direction is different from appointment of PER4935 NO MATCH the tool tip setting. EX4936 TOOL PRESETTER Presetter repeat command is not finished. PER4936 REPEAT ERROR Please confirm whether a position is normal. EX5004 CHECK PROGRAM PER5004 By reset process, modal information such as START POSITION offset data are cancelled. Starting the program as it is may result in machine interference.
again. EX5009 ZERO RETURN Y AND X Try reference position return of Y axis first, then PER5009 AXIS IN ORDER X axis next. EX5014 AXIS POSITION Turret index command has not been accepted by PER5014 IMPERFECT incorrect axis position. EX5015 Turret index command has not been accepted by Y-AXIS POSITION PER5015 incorrect Y-axis position. Or Y-axis is over the IMPERFECT stroke limit. EX5016 AXIS NEED ZERO A cycle start command has been given while axis PER5016 RETURN is not at the zero point. EX5050 CHIP CONVEYOR AT Using link-single change switch, chose the link- MER5050 INDEPENDENT OP. mode.