Professional Documents
Culture Documents
8663AM
8663AM
8663AM
LIFTING CAPACITIES: Lifting capacities for various MACHINE TRAVEL: Machine to travel on a firm, level
boom lengths and operating radii are for freely suspended loads and uniformly supporting surface and boom within boom angle
and do not exceed 75% of a static tipping load. Capacities based range shown in capacity chart. Refer to Swing and Travel
on structural competence are denoted by an asterisk (*). Specification chart No. 8664-A.
Note 1: Capacities above 600 000 kg thru 661 200 kg require OPERATING RADIUS: Operating radius is horizontal
55A boom top. distance from axis of rotation to center of vertical hoist line or
load block. Boom angle is angle between horizontal and
Hanging counterweight must be attached to support beam and centerline of boom butt and inserts, and is an indication of
MAX-ER mode must be selected to operate. Minimum boom operating radius. In all cases, operating radius shall govern
capacity to raise hanging counterweight free of ground support capacity.
is required for swing and travel. Do not allow hanging
counterweight to contact ground while swinging and traveling. BOOM POINT ELEVATION: Boom point elevation is
Exit MAX-ER mode before operating without hanging vertical distance from ground level to centerline of boom point
counterweight. shaft.
MACHINE EQUIPMENT: Machine equipped with
Simultaneous hoisting of both load drums is required for even
MAX-ER, 11 811 mm crawlers, 1 524 mm treads, 9.1m live
block travel.
mast, 42.7m mast, 16 part boom hoist reeving, boom support
Weight of all load blocks, hooks, weight ball, slings, hoist lines, straps, 223 170 kg crane counterweight, 145 150 kg carbody
etc., beneath boom point sheaves, is considered part of main counterweight and hanging counterweight as specified.
boom load. Boom is not to be lowered beyond radii where WARNING: Check amount of hanging counterweight on
combined weights are greater than rated capacity. Where no machine before use of this chart. Refer to
capacity is shown, operation is not intended or approved. Counterweight Assembly.
OPERATING CONDITIONS: Machine to operate in a
level position on a firm uniformly supporting surface with mast Upper Boom Point Capacity
up. Refer to boom rigging No. A05377, Wire Rope For Liftcrane Service - Whip Line
Specification chart No. 8573-A or 8573-B and Counterweight
Arrangement chart No. 8577-A. Crane operator judgment must 28 mm 32 mm
be used to allow for dynamic load effects of swinging, hoisting Drum 2 Drum 3 Drum 2
or lowering, travel, wind conditions, as well as adverse
Single Part Line
operating conditions and physical machine depreciation. Refer
to Operator’s Manual for operating guidelines. 16 240 kg 13 610 kg 22 140 kg
Two Part Line
Maximum Boom Lengths Lifted Unassisted Upper Boom Point No. 170419
Over End Over Side or End 27 220 kg 27 220 kg 27 220 kg
of Blocked Crawlers of Unblocked Crawlers
Upper Boom Point No. A08516
With 0 kg Hanging Counterweight
32 480 kg 27 220 kg 44 270 kg
103.6m 91.4m
In all cases, upper boom point capacities
Over Side or End of Unblocked Crawlers cannot exceed those listed for main boom
With 112 400 kg With 212 190 kg - 391 810 kg capacity.
Hanging Counterweight Hanging Counterweight
121.9m 134.1m
Load block, hook and weight ball on ground at start.
8663-AM, 4-5-05/L
Page 1 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 2 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 3 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 4 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 5 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 6 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 7 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 8 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 9 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 10 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 11 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 12 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 13 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 14 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 15 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 16 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 17 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 18 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 19 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 20 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 21 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 22 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 23 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 24 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 25 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 26 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 27 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 28 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 29 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 30 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 31 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 32 of 33
Manitowoc Cranes, Inc.
Manitowoc, Wisconsin 54220 U.S.A.
8663-AM, 4-5-05/L
Page 33 of 33