Professional Documents
Culture Documents
Letter No 1497 Dated 27 07 2022 (Public Comments) Kanpur
Letter No 1497 Dated 27 07 2022 (Public Comments) Kanpur
19001/1/RO-W-UP/NH-27/Km. 1398.600 -
1437.000/UG/ IWR Dated: 27.07.2022
Invitation of Public Comments
Sub: Proposal for NOC permission for laying of Water supply pipeline parallel and
road crossing on NH-25(New NH-27) Jhansi-Orai Section at (Chainage
1398+600 to 1437+000 km) LHS/RHS from Village-Digara to Village-Amargarh
section 250 mm dia to 700 ms casing pipe in the State of Uttar Pradesh for
approx 40.600 km reg. -
The Authorized Signatory M/s U.P. Jal Nigam has submitted the proposal for
NOC permission for laying of Water supply pipeline parallel and road crossing on NI
2a(New NH-27) Jhansi-Orai Section at (Chainage 1398+600 ta 1437+000 km) LHS/RHS
from y to Vittage-Amargart section 250-mmTrdia to-700-ms casing pipe in
the State ot Uttar Pradesh for approx 40.600 km.
2. As per the guidelines, issued by Ue Ministry vide OM Nu.RW/NH-33044/29/
2015/ S&R(R) dated 22.11.2016, the application shall be put out in the public domain
for JO days fur seeking clains and abjecuons (an grounds of public inconvenience,
safety and general public interest).
3. In view of the above, comments of the public on the above application is invited
to the below mentioned address, which should reach by this office within 30 days from
the date of publication beyond which no comments shall be entertained.
wert pratera: o-5 we 6, Aaet-10, arnt, we ail -110075 e GANT: 91-11-25074100, 200_@ dame: www.nhaigovin
Corporate Office G-5 & 6, Sector -10, Dwarka, New Delhi -110075 @ Phone : 91-11-25074100/200 @ Website www.nhai.gov.in
:
CHECK LIST
Guidelines for Project Directors for processing the proposal for laying of Water Supply Pipeline in the
land along NH-27 vested with NHAI.
CHECK LIST FOR GETTING APPROVAL FOR LAYING OF WATER SUPPLY PIPELINE ON NH-27
YES, No Addition
land is not to be acquired al land is to be acquired to All Goy, W/$ Schemes
A
accommodate pipeline
N/A
Field gineer
TES-'v £SLW.V.)
x" be "
S.No. Item Information/Status Remarks
(a) Left side from center line
(b) Right side from center line
1.15 Proposed Service Road
(a) Left side from center line
N/A
N/A
aaw
(b) Right side from center line
1.16 Whether proposal to lay water supply pipeline Permi.ceion
is after the service road or between the service After and Between the service
road and main carriage way road, as per site condition where Cawice
land is not available outside the
RoW Pow.
Fromch. 1400.2 to 1401.4 (Both
Side of Road)
1. 17 The permission for laying of Water Supply Asstt. Hightvay Mair tenance Enginee:
Pipeline shall be considered for approval/ Lion Engineering Consultants Pvt. Ltd
rejection based on the Ministry circulars JHaus -Orai Seetion, MN-27
mentioned as above
(a) Carrying of sewerage/ gas pipelines on
highway bridges shall not be permitted as HighWay Maintendnce Engineer
Furmes/gases pipes can accelerate the process Lion
Engineering Consultants Pyt. Ltd.
of corrosion or may cause explosions, thus, N/A . Jhansi-Orai Section, NH-27
being much more injurious than leakage of
water n eam bea er
(b) Carrying of water pipelines on bridges shall
.
TES 2
5 Manoj enes al Nayak
Engin Support Engineer
TES-W ESI TES WTES] UV.)
-
PAtC PMC.Jhansi 2
c Sav, WIS Schemes¥4 oo
dee
2 MC, Jhansi
S.No. Item Information/Status
the outer diameter of the pipe
(ii) located as close to the extreme edge of the
vt. Ltd,
2.4.1 Open trenching method. (May be allowed in The pipeline is accommodate in PRlTy (ats:
utility corridor only when pavement is neither
cement concrete nor dense bituminous concrete
type. If yes, Methodology of refilling of trench. Method
(a) The trench width should be at least 30 cm,
but not more than 60 cm wider than the outer Yes
diameter of the pipe.
(b) For filling of the trench, Bedding shall be to
a depth of not less than 30 cm. It shall consist
of granular material, free of lumps, clods and As per Cross Section
cobbles and graded to yield a firm surface
without sudden change in the bearing value.
Unsuitable soil and rock edged should he
r
Gey. WIS Scheme PMC, Jhansibees
WS Se
S.No. Item Information/Status Remarks
as the material that had been removed.
Consolidation by saturation or ponding will not
-be permitted.
(e) The road crust shall be built to the same ;
vt. Ltd,
*
meter (parallel! to NH) and
rt Enygineet
S
fay WIS Scheme
S.No. Item Information/Status Remarks
to pay the losses to either NHAI or to the
concerned agency.
5.2 Renewal of Bank Guarantee Yes, Enclosed at page no.
t WUNUUSSPond'
dh
sh
TS Uy Yes;.
then the Same has to be paid by the applicant
Tea m Leak er
5.8 Prior approval of the NHAI shall be obtained Yes, brorrengin ering
Consultants Pyt. Ltd
before undertaking any work of installation, Jhans}-Orai
Section, NH-27
shifting or repalrs, or alterations to the showing
Water Supply Pipeline located in the National
Highway Right of ways. 5
5.9 Expenditure, if any, incurred by NHAI for Yes,,
repairing any damage caused to the National
Highway by the laying, maintenance or shifting
of the Water Supply pipeline will be borne by
the agency owning the line. thangsi
5.10 If the NHAI considers it necessary in future to Yes,
move the utility line for any work of
improvement or repairs to the road, it will be Kumar
carried out as desired by the NHAI at the cost Supervi on Engineer
of the agency owing the utility line within a ES-w ESL (J.V.)
reasonable time (not exceeding 60 days) of the Jhansi
intimation given. Ss Schemes
Certificate from the applicant in the following
5.11
furmal
AS
yo
(i) Laying of Water Supply pipeline will not
have any deleterious effects on any of the
bridge components and roadway safety for
traffic. Harish OKAMira
Ara Nat k
Kunal Naya
" Lea efneer
(ii) For 4 laning We do undertake that I will
relocate service road/ approach road/ utilities at IV.) TE West
tors WU. STFA nsi
Pvt. Ltd.
(J.V.)
Gtr. WS Sche: 7
Mant} Riera
Field Enginesr
TES -
TES WTESL0.V.)
-
MC, thansi
PMC, jhansi
14
0
ta. Gov. WIS Schemes
Gov. WIS Scheme
S.No. Item Information/Status Remarks
Operate and Transfer Basis] and therefore, the
licensee shall honour the same" SwsM
9 Who will supervise the work of laying of Executive Engineer, oof
or
National H1
Authority of Tat Team Leader
PI. U.,Kanmir
NHAI, Site Office, Jhansi vt. Ltd.
Lion Engineering Consultants
Executive Engineer Jhansi-Orai Section, NH-27
Cénstrection Division
U xecutive EnginetsPy Saf NigastyJHANSI Signature of Project Director
Division,
Jhansi U.P.) Cone
Ashwa ar
TES W] -
L(V.)
PM
fo >
Man Kumar F
©
agineer
E gi Mukésh Rumap
WS} *
TES SL (J.V.) V.)SuPervision Engineey
ay ansi PMC, Jhansi TE S TESL (J
af chemes Gu ara Gov WIS Scheme Pp M
C, Shansi
Gulara
'ira All Gov. W/S Sch
emes
g
Ad N.)
Kunal Nayak mes
Supper E.ng neer
TES WTESL(I.V.)
- Ail GY* 8.
PMC, Jhansi
Cau AHO