Impedancia: Phase To

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

CT Ratio Prim./Sec. Iee2 60.

0
VT's Value
Rted Primary Voltage 13.80 kV
Rated Secondary Voltage (Ph-Ph) 115 V
UE Connection UE Conn to Neu.
VT Ratio Prim./Sec. Ue 34.6
Power System Data 2 Value
Meas. of Active Power for Generator
Impedance 3-ph. 21 Ajustes Sec. Primarios Impedance Protection Distance Ajus
Operate Value 5.0 Ohm 0.150 Ohm General Value Primarios Source SR
Current Interlock 1.05 A 4200.0 A Impedance Protection ON Memory Duration 10 cy
Time Delay Imp. 0.50 s Fault Detection I> Pickup 1.05 A 120 % Force Self-Polar OF
Time Delay Cur. 3.00 s State of Undervoltage Seal-in OFF Force Mem-Polar OF
Undervoltage Seal-in Pickup 80.0 V 69.6 % Fast Distance Enab
Duration of Undervoltage Seal-in 4.00 sec Ph Dist Ph Select Supv Enab
T END: Final Time Delay 3.00 sec Phase Distance Z1 Ajus
Zones Value Primarios Function Enab
Impedance Zone Z1 5.00 Ohm 0.150 Ohm Direction Non-dire
Impedance Zone Z1 Time Delay 0.50 sec Shape Mh
Impedance Zone Z1B 10.51 Ohm Xfmr Vol Connection No
Impedance Zone Z1B Time Delay 2.00 sec Xfmr Curr Connection No
Impedance Zone Z2 10.51 Ohm 0.315 Ohm Reach 5.00 O
[21] Impedance Zone Z2 Time Delay 2.00 sec RCA 90 d
IMPEDANCIA Rev Reach 5.00 O
Rev Reach RCA 90 d
Comp Limit 90 d
DIR RCA 90 d
DIR Comp Limit 90 d
Quad Rigth Blinder 10.00
Quad Rigth Blinder RCA 90 d
Quad Left Blinder 10.00
Quad Left Blinder RCA 90 d
Supervision 0.20
Volt Level 0.00
Delay 0.50
Block OF
Target Latc
Events Enab
Overfluxing 24 Ajustes Sec. Primarios Overexcitation Protection (U/f) VOLTS PER HERTZ 1 Ajus
Setting St.1 1.15 Overexcitation Value Primarios Function Enab
Time Delay St.1 3.00 s Overexcitation Protection (U/f) ON Source SR
Setting St.2 1.25 U/f> Pickup 1.15 VHZ Voltage Mode Phase to
Time Delay St.2 1.00 s T U/f> Time Delay 3.00 sec Pickup 1.15
Nom. Volt. 115.0 V U/f>> Pickup 1.25 Curves Definite
Nom. Frequ. 60.0 Hz T U/f >> Time Delay 1.00 sec TD Multiplier 3.0
Characteristics Value Primarios T Reset 1.0
U/f = 1.05 Time Delay 2000 sec Block OF
U/f = 1.10 Time Delay 6000 sec Target Latc
[24]
U/f = 1.15 Time Delay 3 sec Events Enab
SOBRE
U/f = 1.20 Time Delay 3 sec VOLTS PER HERTZ 2 Ajus
EXCITACION
U/f = 1.25 Time Delay 1 sec Function Enab
U/f = 1.30 Time Delay 1 sec Source SR
U/f = 1.35 Time Delay 1 sec VHZ Voltage Mode Phase to
U/f = 1.40 Time Delay 1 sec Pickup 1.25
Time for Cooling Down 3600 sec Curves Definite

You might also like