Professional Documents
Culture Documents
Ancon EdjPro EPHIMini Edge Lifting System
Ancon EdjPro EPHIMini Edge Lifting System
Lsy.tb
30 2.0 2.5
15 2.0 2.5
150 N16
30 2.3 3.0
15 2.5 3.0
175 N16
30 2.7 3.5
15 3.0 3.5
200 N16
30 3.5 3.5
w
Notes: Locate the perimeter bar above the EdjPro anchor to control flexural cracking. N12 shear ‘omega’ bars and edge reinforcement e.g. hooked or U-bars help control shear
cracking at higher loads. The standard shear bar is optimised for 125-150mm thick panels. Multiple bars or larger diameter bars with deeper embedment may improve crack control in
thick (175-200mm) panels. Panel cracking and shear spalling is possible if the designed loads are exceeded. Some anchor deflection is normal, particularly at large sling angles.
For other panel thicknesses, please consult the Leviat technical team for design advice. The WLLs shown in the tables above are based on a minimum distance equal to the panel
thickness between an anchor and any edge or penetration (e.g. a duct) and twice this distance between any two anchors.
EdjPro EPHIMini Anchor Standard Hot Dip Galvanised N12 ‘W’ Shear Bar EPSB4-7-150G
Narrow body and high capacity, perfect for thin panels.
62mm
Shear bar notch Tension bar aperture
250mm
EPHIMini
40mm
EPHIMini
34mm EPHIMini Trimmer Bar & EPSB4-7-150G Shear Bar in 150mm Panel
EdjPro
EdjPro
Trimmer
Trimmer bar
bar
150mm
80mm
21mm N12
N12 shear
shear bar
bar
200mm
Preferred Rigging: Use a beam to minimise stresses
EdjPro Recess Former EPRFMini
Ultra narrow design, oil resistant synthetic rubber.
M8
Ø11mm
EdjPro
EdjPro
EPRFMini
EPRFMini
50mm 50mm
April 2021
Important! The EPHIMini must be installed with the EPRFMini (or EPNRF07) recess and lifted with the EPLCMini clutch (or the compatible but now
superseded EPLC07). This system is not compatible with other components without written authorisation from Leviat.
Leviat
98 Kurrajong Avenue, Mount Druitt, Sydney, NSW 2770
1300 304 320
info.ancon.au@leviat.com
New South Wales | Victoria | Queensland | Western Australia