Professional Documents
Culture Documents
Aroma Service Manual
Aroma Service Manual
Aroma Service Manual
WARNNING
DO NOT OPEN THIS CONSOLE EXCEPT FOR THE AUTHORIIZED PERSON BY THE
MANUFACTURER. A/S COULD NOT BE PROVIDED BY THE MANUFACTURER.
( IF CAN NOT BE OPERATING PROPERLY AND CAUSED A PROBLEM & A FAULTY OF
THE EQUIPMENT .)
There is no DI WATER currently. Please use after add DI WATER.
When you combine body and handpiece, the both S/N number should be same.
radiator
water tank
water pump
water filter
smps RSP1500-12
smps 100-24
smps 100-12
noise filter
LCD
TOUCH PANEL
Control BOARD
Drive BOARD
Handpiece
The method of adding DI WATER and testing method
If you see inner part, there is yellow line at WATER TANK. Add DI WATER up to yellow line.
Add DI WATER using enclosed funnel and fitting. The fitting is for removing air so you must
set fitting.
After fill DI WATER and before connect handpiece, connect enclosed test line and then
operate AROMA.
water line
If Aroma is delivered to your company, Add DI water in.
Don’t connect Handpiece.
Connect above two parts to the Aroma body.
After checking, if Flow switch is pressing sensor itself, connect handpiece.
Combined condition
When you combine body and handpiece, the both S/N number should be same.
Same as above photos, the S/N of sticker on back of main board should be same as S/N of
handpiece connection terminal.
Check list
1)
If the Circular red button, emergency switch (at top left ) is pressed, the machine is not
working. Move the switch to clock direction, make usable condition and then use
handpiece body
The hand piece and back of main body should be joined firmly. You have to Check the sound
and make sure that both are joined properly. ( Check the ‘Click’ sound over red arrowed
parts)
4)Right side of upper part of body, move key switch to clock direction (90 degree), the
machine will be worked.