Professional Documents
Culture Documents
ComfortInnBk
ComfortInnBk
Fabric Selection:
Face: Pattern - Color Liner: Pattern - Color
Please fax your completed form to Koni Corporation 619.671-9732. A Koni representative will contact you regarding your order.
For questions or additional information, please contact Customer Service toll free at 800.367.5664
An UPGRADE Option is available: the Coverlet can be reversible instead of using a lining; additional charges will apply
Please request pricing for this UPGRADE when you place your order.
Quilt Pattern 8" Diamond
Fabric Tier 1 Options: Blockbuster - (1) Earth, (2) Linen, (3) Mushroom, (4) Olive
Tier 1 Options: Galaxy Stripe - (1) Corn, (2) Wine, (3) Earth, (4) Olive, (5) Passion Blue
Tier 1 Options: Radiant - Linen
Tier 1 Options: Harlequin - Mushroom
Tier 1 Options: Colonnade - (1) Gold, (2) Mushroom
Tier 1 Options: Wave - (1) Emerald, (2) Navy, (3) Sand, (4) Wine
Tier 2 Options: Indulgence - (1) Cobalt, (2) Garnet, (3) Maize, (4) Umber, (5) Olive
Tier 3 Options: Stockton - (1) Riverbed, (2) Seaweed
Bed Skirt
Style Tailored
Kick Pleats 4 inverted pleats on Double & Queen size. 5 for King size
Box Fit Decking and platform extended 5" at the top and sewn to the side drops for a tight fit.
Liner None
Platform Strips 4" Platform strips with self fabric
Decking 70/30 polyester/cotton
Edge Detail 1" double turned single needle hem
Fabric NOTE: Per Choice Hotel International recommendations, bedskirt fabric must be the same as the face fabric on the coverlet
* Drop Our standard drop is 14". Please verify the drop required for your beds by completing the attached measurement form
and sending it with your order
Measure the bed with a steel tape, the width x length x drop. To recheck total width of
bedspread, measure from floor to floor as shown.
Mattress Thickness �
Length (_____________)"
(_____________)"
(_____________)"
DO:
• Wash and dry in warm temperature not to exceed 120 F (50C).
• Wash with mild surfactant detergent.
• Use the gentle cycle for washing and drying.
• Use PreClean spot remover for small stains. (See below for information)
• Wash and dry separately from other textiles.
• Close all zippers before washing.
• Check for burrs inside the washing machine and dryer periodically and smooth out the
roughness inside before putting in any items.
• If the are any burrs inside the washing machine and dryer, put all items
inside a mesh bag before washing or drying.
• Remove all items from the washer and dryer as soon as the cycle is over.
• Test ONE set in the washer and dryer. If the result is satisfactory, proceed to wash and
dry the others sets. (Koni is responcible for the test item only, if an undesirable result
occurs.)
DON'T:
• Use HOT water exceeding 120F (50C).
• Use HOT temperature in dryer exceeding 120F (50C).
• Use alkaline detergent.
• Use chlorine bleach or hydrogen peroxide
• Use sour (acid).
• Use solvent for stains.
• Use fabric softener in either the washing or drying cycles.
• Mix with any other textile.
• Leave the zippers open.
• Use washing machines or dryers with burrs inside.
SPOT REMOVER:
Apply PreClean spot remover to the spot and gently rub it into the fabric. Let it sit for 10
minutes. Hand wash the spot in lukewarm water, or use wet cloth on the spot or wash as
instructed above. For stubborn stains, brush lightly after applying the spot remover and repeat the
process.
NOTE: Ironing is not necessary if the above instructions are followed. Avoid HEAT, CHLORINE
and FABRIC SOFTENERS. They are the fabrics worst enemy.