PARUL UNIVERSITY - Faculty of Engineering and Technology
Department of Aeronautical Engineering
SYLLABUS FOR 3rd Sem BTech PROGRAMME
Analysis of Mechanism & Machine Elements (203101217)
‘Type of Course: BTech
Prerequisite: Fundamental Knowledge of Mechanics of Solids and Engineering Mechanics.
Rational
‘The subject is mainly focused on various mechanism used in locomotives and
prime movers. Force analysis and balancing of locomotives under different dynamic
condition are also covered in the subjects.
‘Teaching and Examination Scheme:
‘Teaching Scheme Examination Scheme
tecties/| Tae | tabsire|
Week | sy
credit
External Internal
Total
pat T P T
ck
3
o fe [s 60 - 20
20
100
‘Det- Lecture Tut- Tutorial Lab Lab, T-Theory, P-Pracical CB- CET Theory, P-Practial
Contents:
sr.
Topic
Welghtage
[reaching
Hrs.
introduction to Mechanism & Machine:
15%
06
lVelocity and Acceleration Anal
Velocity analysis: Absolute & relative motion, vectors, motion|
lof a link, Velocity analysis of four-link mechanism & slider|
crank mechanism, angular velocity of links, velocity of|
rubbing, I- centre method, Kennedy's theorem, and centrode,|
|Acceleration analysis: Acceleration, Acceleration analysis of|
four-link mechanism & slider crank mechanism, corioli's
acceleration component, crank & slotted lever mechanism.
25%
10
Force Analysis:
Static force analysis: Introduction to static force analysis}
Jsuperposition, principle of virtual work, Dynamic force|
lanalysis: D Alembert's principle, dynamic analysis of slider
cranks chain, velocity & acceleration of piston, engine forcel
analysis, inertia of connecting rod.
20%
09
Riveted & Welded Joints:
20%
10Design of Shafts:
‘Types of shafts, material of shafts, ASME codes for shaft design,
stresses in shaft, design of shafts subjected to twisting momen
only, design of shafts subjected to bending moment only] 459, 10
ldesign of shafts subjected to combined twisting & bending|
design of shafts subjected to axial load in addition to combined
twisting & bending. Combined twisting & bending, design o
shaft on the basis of rigidity
Continuous Evaluation:
It consists of Assignments/Seminars/Presentations/Quizzes/Surprise Tests
(Summative/MCQ) ete.
Refer
1
2
3
4
srence Books:
‘Theory of Machine (Textbook) $ § Ratan; Tata McGraw Hill Publishing
‘Theory of Machines and Mechanisms J E Shigley; Oxferd University Press
Design of Machine Elements (Textbook) V B Bhandari; 3/e, McGraw Hill
Design of Machine Elements RS khurmi; S.Chand Publication
Course Outcome:
After Learning the course, the students shall be able t«
1
2.
Understand the principal and various laws useful for analyzing any mechanism,
Understand various theorem used for solving various problem of kinematics and
dynamics.
3. Carty out the force analysis for any dynamics problems
Explain various balancing method used in locomotives and prime movers,
Design the riveted and welded joints required for joining the wall structure elements
for air frame
Design of structural elements, which are subjected to torsional and bending
moments.