@scm
[70 = Maintenance — EN
very 80 hours: lubricate the tool taper clamp ‘he grease soray Provide
clamping unt win tne %
KLUBER GRAFLOSCON - code. (A) 00103003908 yeyoow0400se1— V
LUSIN LUB PM 1004 - code: (A)+(B) 0002400035C i:
Uolond te too te tools eno ;
‘Move the operator unit to an accessible c
cessible position, car a
ana hosing ee
Move line spray can tube in the gap between two of the collet sections
50h
ina vertical position, spray.
Topeal the operation for the other gaps
or a correct distibution of the grease between the pedals of the
Foes necossary Wo activate the locking unlocking cone t201
carp nction ito the emergency conditon. Execute iis
procedure
Machine state operating
{flection MD! 1SO page
en)
Selection the elactrospindle by the code MB1 (or M31-MGz2 in BASS rs
=
to the type ‘of machine) activating it with “Enter” ~ and “Start |
cycle”
‘
‘atvate the emergency of the machine: the key “TO8" is operating
- Rata the lockingluntocking cycles by the key "TOS" almost 10/1°
cycles) 9 9
nthe reset from emergency of the machine the Key TOE” are
disabiltes
Toranctivate the machine, first reset the messages with the F11
LBD keys.
Dasoiplion/ Function
imi a
(= age | pevand/orindeaton
TISKG3 cone: Enabled in "MDI" and
Button for locking-unlocking the
T06a oe SManual’ mode: not enabled in “Automatic: mode
.ed in position
The light is steady when the cone is lock
[ 26 ing the HSKE3 cone: Enabled in =MDI and
TO6b | +>
Button for locking-unlock
[ene mode: not enabl
ied in “Automatic: mode
Loca och
Insert an emply cone and have the electric spindle rotate at 18000 rpm for about a menue
‘atthe ond, stop the machine again, exract ne 10°) Zone and eliminate any grease deposited on
syan witha Goth and, f necessary, with acetone S
the inside walls of the electric spindle
(WARNING: ACETONE IS & FLAMMABLE LIQUID!)
98 sir
cause irreparable damages {0
inside the spindle as it could push dust and dirt inside and
the spindle.