Professional Documents
Culture Documents
Srs DTC b1032 b1187
Srs DTC b1032 b1187
Srs DTC b1032 b1187
NOTE: If you are troubleshooting multiple DTCs, be sure to follow the instructions in B-CAN System
Diagnosis Test Mode A (see page 22-92).
YES-Go to step 5.
NO-Intermittent failure, the gauge control module is OK at this time. Check for loose or poor
connections at the gauge control module 36P connector and the under-dash fuselrelay box
connector Q (16P). If the connections are good, check the battery condition (see page 22-65) and the
charging system..
Are DTCs 81008 and 8101 1 also indicated with DTC B1032?
YES-Check for an open in the communication circuit between the MlCU and the gauge control
module. If the circuit is bad, repair the open circuit.
----------------------------------------------------------------------------------------------------------------------------------
DTC B1187: Gauge Control Module Lost Communication with the SRS Unit (SRS Message)
NOTE: If you are troubleshooting multiple DTCs, be sure to follow the instructions in B-CAN System
Diagnosis Test Mode A (see page 22-92).
YES-Go to step 5.
NO-Intermittent failure, the system is OK at this time. Check for loose or poor connections between
the gauge control module and the SRS unit..
5. Check for SRS DTCs with the HDS.
NO-Go to step 6.
9. Check for continuity between the gauge control module 36P connector No. 33 and No. 34
terminals and the SRS unit connector A (28P) No. 12 and No. 11 terminals respectively.
Is there continuity?
CANL (RED) Q
YES-Substitute a known-good SRS unit, and recheck. If the indication goes away, replace the original
SRS unit. If the DTC is still present, replace the gauge control module (see page 22-248). . NO-Repair
an open in the wire..