Professional Documents
Culture Documents
QG40N KIXv XXX ASP CM UL
QG40N KIXv XXX ASP CM UL
QG40N-KIXv-xxx-ASP-CM-UL
Tilt switch
programmable
1 axis vertical mounting
Output
PNP
Supply voltage
8 - 30V dc
Measuring range
Switch points
up to ± 180°,
programmable by factory or
QG40N configurator
© DIS Sensors - Oostergracht 40 - 3763 LZ SOEST - The Netherlands www.dis-sensors.com Subject to change without notice Page 1 2017-03-27
QG series
QG40N-KIXv-xxx-ASP-CM-UL
Transfer characteristic
PNP-output:
- Programmable switchpoints ±S
- at 0°: safe area, conducting
- outside ±S: unsafe, non-conducting
- Unpowered sensor: non-conducting
Factory defaults:
- output 1: S = ±10°
- output 2: S = ±50°
- hysteresis : 0,2°
- safe ► unsafe delay : 500 mS
- unsafe ► safe delay : 1000 mS
Measurement orientation
QG series sensors are intended to measure inclination, acceleration or tilt angle after installing in machines, equipment
and systems. Flawless function in accordance with the specifications is ensured only when the device is used within its
specifications.
This device is not a safety component according to the EU Machine Directive (ISO13849). For full redundancy two
devices can be used in the application. Modifications or non-approved use are not permitted and will result in loss of
warranty and void any claims against the manufacturer.
© DIS Sensors - Oostergracht 40 - 3763 LZ SOEST - The Netherlands www.dis-sensors.com Subject to change without notice Page 2 2017-03-27