Professional Documents
Culture Documents
Appah Precious MayReport
Appah Precious MayReport
Here are some additional tips for using a dummy load to test
two transmitters:
Use a wattmeter to measure the power output of the
transmitters. This will help you to ensure that the dummy load
is not being overloaded.
Start with a low power setting and gradually increase the power
until you reach the desired level. This will help to prevent the
dummy load from overheating.
Monitor the temperature of the dummy load during testing. If
the temperature gets too high, reduce the power output of the
transmitters.
Disconnect the dummy load from the transmitters when you
are not using it. This will help to prevent it from being
damaged.
* Two transmitters
* A dummy load
* A coaxial switch
* Coaxial cables
Here are some additional tips for using a dummy load to switch
between two transmitters: