Professional Documents
Culture Documents
Ts-Intermediate Exam - 2023
Ts-Intermediate Exam - 2023
© 2021 Trimble, Inc - All Rights Reserved - Confidential and Proprietary Information
Level :
Certification Exam
Intermediate
General Notes
Create a new Tekla Structures model using South-East Asia environment
Save the model asTS_Model_[Your Name]
1. All dimensions are in mm.
2. Grade of Steel is S275, unless noted otherwise
3. Grade of Concrete is C40, unless noted otherwise
4. Type of all Concrete is Cast in Place, unless noted otherwise
5. All welds are 6mm continuous fillet, unless noted otherwise.
6. Bolt is of 8.8 XOX grade
7. There are 4 Sections –Answer All question
Section A - 3D Structure Model – 30 Marks
Size:
1200*1200*850
Section A-(3)-Create Slab (4 Marks)
Create Slab
Thickness:
300 mm
Section A-(4)-Create Columns (5 Marks)
Create Columns
Profile:
UC203*203*49
UC305*102*25
Section A-(5)-Create Rafters (5 Marks)
Create Rafters
Profile:
UB305*102*25
Section A-(6)-Create Braces (5 Marks)
Create Braces
Profile:
L-80x80x6
Section B - Detailing– 30 Marks
Create
Component:
-Eaves Haunch
#102
-Apex Haunch
#106
Note:
In case of no detail, use
component default
setting
Section B - (2) - System Component Detail (2 Marks)
Create Component:
-Stiffened Base
Plate
#1014
Note:
In case of no detail, use
component default
setting
Section B - (3) – Manual Cut and Bolt (4 Marks)
-Pad Footing
Reinforcement
#77
-Starter Bars for
Footing
#87
-Columns Automated
Reinforcement Layout
#57
-Rebar Set
by Face
Create Overall 3D
View GA Drawing
-Use Standard GA
Properties
Section C - (2) – Plan and Elevetion Drawing (5 Marks)-Drawing 2
-Use Standard GA
Properties
-Modify Drawing
Name, and titles
Section C - (3) – Detail and Section View (5 Marks)-Drawing 2
-Open GA Drawing in
Section C-2
- -Create Detail 1
- Place in same
drawing
Section C - (4) – Detail and Section View (5 Marks)-Drawing 2
-Open GA Drawing in
Section C-2
- -Add Dimension in
Section B-B
- -Add Marks in
Section
- A-A & B-B
Section C - (5) – Add Texts and Cloud (5 Marks)-Drawing 2
-Open GA Drawing in
Section C-2
- -Add Cloud as
following
Section C - (6) – Create Assembly Drawing (2 Marks)
-Create Fabrication
Drawing For Column in
Grid A-1
-Use standard
Assembly Drawing
Properties
- -Complete Drawing
Information in
Assembly Drawing
Section C - (6) – Create Single Part Drawings (2 Marks)
-Open Fabrication
Drawing For Column in
Grid A-1
- -Complete Drawing
Information in
Single Part Drawing
Section C - (6) – Create Cast Unit Drawings (2 Marks)
-Create Fabrication
Drawing For Pad
Footing in Grid A-1
- -Set Reinforcement
to shown all in
double lines
Section D – Report and IFC Report– 10 Marks
Keep SAFE,
Keep HEALTH.. !
© 2021 Trimble, Inc - All Rights Reserved - Confidential and Proprietary Information