Download as pdf or txt
Download as pdf or txt
You are on page 1of 7

https://www.dumpsbase.com/300-135.

html

Cisco 300-135. Exam Dumps


1.Ticket 4 NATACL

TROUBLE TICKET STATEMENT:

The implementation group has been using thetest bed to do a ¡®proof-


of-concept¡¯that required both client 1 and client 2 to access the Web
Server at 209.65.200.241.After several changed to interface status,
network addressing, routing schemes and layer 2 connectivity, at
trouble ticket has been opened indicating that client 1 cannot ping the
209.65.200.241 (internet Server).
show run by yourself to obtain the following information:
Configuration on R1
ip nat inside source list nat_pool interface Serial0/0/0/1 overload !
ip access-list standard nat_pool
permit 10.1.0.0
! interface Serial0/0/0/1
ip address 209.65.200.224 255.255.255.252
ip nat outside
! interfaceSerial0/0/0/0.12
ip address 10.1.1.1 255.255.255.252
ip nat inside
ip ospf message-digest-key 1 md5 TSHOOT
ip ospd authentication message-digest

On Which device is the fault condition located?


A. R1
B. R2
C. R3
D. R4
E. DSW1
F. DSW2

page 1 / 7
https://www.dumpsbase.com/300-135.html

G. ASW1
Answer: A

2.What is the MTU¡¯s size in a GRE tunnel?


A. 1630
B. 1476
C. 1500
D. 1900
Answer: B

3.The tunnel between R1 and R3 is not coming up. Which two


statements are true? (Choose two)
(Topology with a GRE tunnel and the outputs provided are show ip int
brief and tunnel source and destination)
A. Tunnel source int Eth0/0 is down
B. No route from R1 to R3 loopback0 (tunnel destination)
C. source and destination not in same subnet
D. http://bbs.hh010.com/
Answer: AB

4.What is the solution of the fault condition?


A. Under the BGP process,enter the bgp redistribute-internal command
B. Under the BGP process, bgp confederation identifier 65001
command
C. Delete the current BGP process and reenter all of the commands
using 65002 as theAS number.
D. Under the BGP process, delete the neighbor 209.56.200.226
remote-as 65002 command enter the neighbor 209.65.200.226 remote-
as 65002 command.
Answer: D

5.R1 and R2 OSPF neighbor.

page 2 / 7
https://www.dumpsbase.com/300-135.html

Which two statements are true? (Choose two)


(Output from show ip ospf neighbors on 2 routers, one of them shows
FULL/DR, the other FULL/-, you need to know how were they
configured and will they exchange routes)
A. They are not neighbors
B. R1 (non-DR) will not update its routes to R2
C. Router R2 is configured with ospf point-to-point command (R2 is the
router that shows as FULL/-)
D. They need to be configured as OSPF NBMA
E. R2 should be configured as stub
Answer: BC

6.Ticket 5 R1ACL

TROUBLE TICKET STATEMENT:


The implementation group has been using thetest bed to do a ¡®proof-
of-concept¡¯that required both client 1 and client 2 to access the Web
Server at 209.65.200.241.After several changed to interface status,
network addressing, routing schemes and layer 2 connectivity, at
trouble ticket has been opened indicating that client 1 cannot ping the
209.65.200.241 (internet Server).
show run by yourself to obtain the following information:
Client 1 is not able to reach the WebServer at 209.65.200.241. Initial
troubleshooting shows that R1 is also not able to reach the WebServer.
R1 also does not have any active BGP neighbor.
Configuration on R1
! interface Serial0/0/0/1
description link to ISP
ip address 209.65.200.224 255.255.255.252
ip access-group edge_security in
ip nat outside
ip virtual-reassembly
ntp brasdcast client
net broadcast key 1

page 3 / 7
https://www.dumpsbase.com/300-135.html

no cdp enable
!! ip access-list nat_traffic permit 10.1.0.0 0.0.255.255
ip access-list nat_traffic permit 10.2.0.0 0.0.255.255
! ip access-list edge_security deny ip 10.0.0.0 0.255.255.255 any
ip access-list edge_security deny ip 172.16.0.0 0.15.255.255 any
ip access-list edge_security deny ip 192.168.0.0 0.0.255.255 any
ip access-list edge_security deny ip 127.0.0.0 0.255.255.255 any
ip access-list edge_security permit ip host 209.65.200.241 any

On which device is the fault condition located?


A. R1
B. R2
C. R3
D. R4
E. DSW1
F. DSW2
G. ASW1
Answer: A

7.Two routers are connected through PPP connection. After the PPP
was established the admin put OSPF running above it. The OSPF
formed adjacency but after soon the adjacency dropped.
What is the reason? (The cause of OSPF forming an adjacency over a
GRE tunnel and dropping immediately)
A. MTU does not match
B. Area 0 need to exist for OSPF to function properly
C. Gre tunnel destination is not reachable through tunnel
D. Gre tunnel ip address must be covered by network under ¡°router
ospf 1¡±
E. ospf routes contains the route to tunnel destination
Answer: C

8.The Fault Condition is related to which technology?

page 4 / 7
https://www.dumpsbase.com/300-135.html

A. BGP
B. NAT
C. IP NAT
D. IPv4 OSPF Routing
E. IPv4 OSPF Redistribution
F. IPv6 OSPF Routing
G. IPv4 layer 3 security
Answer: C

9.What is the solution of the fault condition?


A. Under the interface Serial0/0/0 configuration enter the ip nat inside
command
B. Under the interface Serial0/0/1 configuration enter the ip nat outside
command
C. Under the ip access-list standar nat_trafic configuration enter the
permit 10.2.0.0 0.0.255.255 command
D. Under the ip access-list standar nat_trafic configuration enter the
permit 209.65.200.0 0.0.0.255 command
Answer: C

10.How to check MTU of interface using ping? / How can you check
the links mtu size with ping command?
A. ping 10.1.1.1 size 1501
B. ping 10.1.1.1 size 1500 df-bit
C. ping 10.1.1.1
D. ping 10.1.1.1 no-size
Answer: B

11.Which command will limit debug output ppp authentication on serial


0/1 and serial 0/2?
A. debug condition interface range s0/1 -0/2
debug ppp authentication

page 5 / 7
https://www.dumpsbase.com/300-135.html

B. debug condition interface s0/1 & 0/2


debug ppp authentication
C. debug int s0/1
debug int 0/2
debug ppp authentication
D. Debug condition interface s0/1
Debug condition interface s0/2
debug ppp authentication
Answer: D

12.The Fault Condition is related to which technology?


A. BGP
B. NTP
C. IP NAT
D. IPv4 OSPF Routing
E. IPv4 OSPF Redistribution
F. IPv6 OSPF Routing
G. IPv4 layer 3 security
Answer: A

page 6 / 7
https://www.dumpsbase.com/300-135.html

page 7 / 7
Powered by TCPDF (www.tcpdf.org)

You might also like