Professional Documents
Culture Documents
Questions On Industrial Automations
Questions On Industrial Automations
2. In PLC the user can write the programs with the help of ________
A. Optical isolation
B. Sensing devices
C. Programming devices
D. None of the above
6. Which mode accepts and converts signals from sensors into a logic signal?
A. Input module
B. Output modular
C. Both Input and Output modules
D. None of the above
10. What are the components that make the programmable logic controller work?
A. Power supply
B. CPU
C. Input and Output module
D. All of the above
11. For ON delay timer, which programming bit will be ON after the timer finishes
timing?
A. Timing bit
B. Enable bit
C. Done bit
D. All
12. For ON delay timer, which programming bit will be ON when input is ON and stays
on until the timer finishes timing?
A. Timing bit
B. Enable bit
C. Done bit
D. All
13. For OFF delay timer, which programming bit will be ON if the input is ON and OFF if
the input is OFF.
A. Timing bit
B. Enable bit
C. Done bit
D. All
14. For ON delay timer, which programming bit will be ON if the input is ON and OFF if
the input is OFF.
A. Timing bit
B. Enable bit
C. Done bit
D. All
17. Which gain decides how much correction has to be done on a given system when
error happens?
A. Proportional gain
B. Integral gain
C. Derivative gain
D. All
18. Which gain decides how long the correction has to be done on a given system
when error happens?
A. Proportional gain
B. Integral gain
C. Derivative gain
D. All
19. Which gain decides how fast the correction has to be done on a given system when
error happens?
A. Proportional gain
B. Integral gain
C. Derivative gain
D. All
20. For a given closed loop continuous control system, is it mandatory to use all the
three modes (PID) ?
A. Yes, it is mandatory
B. No, some systems may not need all the three modes
C. No, always use only one mode controller
D. None