Professional Documents
Culture Documents
Barco Lamps
Barco Lamps
Anode and cathode lamp adapters are used to position the arc of the xenon lamp in the middle of the reflector
inside the lamp house. The size of the xenon lamp vary from type to type. Because of that different lamp
adapters are required. Futhermore, some lamp types require an anode adaptation bushing to fit precisely into
the anode support assembly. The table below shows for each supported xenon lamp which anode/cathode
adapters have to be used and if an anode adaptation bushing is required.
All lamps and adapters in the table below must be used with the XL Lamp House (either manual or motorized).
Note that the maximum lamp power the projector delivers depends on the type of projector and the installed
lamp. Prior to install the lamp it’s important to check with the Communicator software if the lamp is listed in
the list of supported lamps for this projector.
Supported lamp types and their respective anode/cathode adapters for the XL Lamp House:
Lamp type / Cathode adapter Anode adapter Anode adaptation Barco Order No.
bushing
Supplier
3000W DHS OFR R8436061K R859987K - R9855950
OSRAM XBO
4500W DHP-OFR R8436081K R859986K - R9855949
OSRAM XBO
6000W DHP-OFR R8436081K - R864132K R98064901
OSRAM XBO
6500W DHP-OFR R8436081K - R864132K R9806860
OSRAM XBO
WARNING: Always use the right adapter(s) for the xenon lamp. Neglecting this may result in poor perfor-
mance of the lamp and damage to the xenon lamp and Lamp House. Some adapters looks the same, therefore
check the engraved item number upon the adapter to ensure you uses the right adapter.
Anode adapters and adaptation bushing
The shortest cathode adapter R8436101K is no longer needed for xenon lamps supported by Barco. For that this adapter has
become obsolete.
7.3 Supported xenon lamps for the S/M Lamp House
Cathode adaptor
A cathode adaptor is required to mount the xenon lamp in the S/M Lamp House. The cathode adapter has to be mounted on the
cathode side of the xenon lamp prior to mounting the lamp in to the Lamp House. The purpose of the cathode adapter is to position
the arc of the xenon lamp in the middle of the reflector inside the Lamp House. Note that there is no anode adaptor for the S/M
Lamp House.
Image 7-10
Cathode adapter S/M Lamp House (R865555K)
All lamps and adapters in the table below must be used with the S/M Lamp House (either manual or motorized).
Note that the maximum lamp power the projector delivers depends on the type of projector and the installed
lamp. Prior to install the lamp it’s important to check with the Communicator software if the lamp is listed in
the list of supported lamps for this projector.
Supported lamp types and cathode adapter for the S/M Lamp House:
Lamp type Cathode adapter S/M Lamp House Barco Order No.
Supplier
4kW DHP OSRAM XBO R865555K R9855937
3kW DHP OSRAM XBO R865555K R9855938
2kW DHP OSRAM XBO R865555K R9855956
1200W DHP OSRAM XBO R865555K R9855959
WARNING: Always use the correct Cathode adapter for the xenon lamp in the Lamp House. Neglecting this
may result in poor performance of the lamp and damage to the xenon lamp and Lamp House. Some adapters
looks the same, therefore check the engraved item number upon the adapter to ensure you use the right
adapter.