Professional Documents
Culture Documents
SART - Ova S9000
SART - Ova S9000
AIS-SART
User Manual
Ownership Details
Vessel Name
Owner Details
Unique ID
9 7 0
○
1 1、Hole: Fixed place
○
2 2、Antenna:Top built-in antenna
3、GPS Area
○
3
4、Test Button: Test AIS-SART
○
4
6、Activation Button: Press the "ON" button, the
device enters the active state
○
5 Test Button
Function 1: Verify that AIS-SART is
○
6 in the ready state
Function 2: long press this button
to turn off the device
Red LED
ON Button
Press the "ON" button to
activate AIS-SART, and the
red LED starts blinking
1
2, Activate the device
Self-test button Self-test button
Self-test steps
Take out the AIS-SART from the installation package,and attach it to the top of
the mounting bar. The mounting bar does not have to be fully extended. Take
AIS-SART outside,high lift it under the sky in the field of vision ,could speed up the
GPS receiver speed. Specific steps as follows:
1. Press the test button until the red LED light up, the buzzer sounds 0.5 seconds;
2. The red LED will blink quickly, it indicate that the test procedure is in progress;
4. When the test is successful, the red LED indicator will flash 3 times;
5. After the completion of the test, the buzzer will short ring 3 times, and automatically turn off
the machine.
If after step 3, the red LED light doesn’t long flash,it indicate the test failed,the
buzzer will short ring 6 times, automatically turn off the machine. But usually it will
not occur,it is recommended to change the position of AIS-SART and re-test again.
2
AIS-SART.
Important hint
○
3
Activate AIS-SART, the buzzer sounds for 0.5 seconds,the LED starts
blinking,flashes once every 3.5 seconds,the signal is transmitted for the first
time after 50 seconds. If error activation,we could turn off AIS-SART during this
time.
4. GPS positioning instructions: red lights short and long flash once per minute, it
indicates GPS positioning well.
GPS normal
Deactivate AIS-SART
3
If error activation or emergency situation end,press the test button for 2
seconds, turn off the device, while the red LED is off.
Important:After activation, replace the protective cover and battery. For details,
please refer to the Service section.
4, Battery
Check the battery if in the period of validity,the battery of AIS-SART should be
changed every 3 year, and the battery expiration date should be marked on the label
of battery pack. Battery must be replaced in time: 1, Battery life expires; 2, AIS-SART
is active for more than 6 hours.