Professional Documents
Culture Documents
Chine Systems Inc Rob Zahensky FR Yer Ma Chine Systems Inc Rob Zahensky
Chine Systems Inc Rob Zahensky FR Yer Ma Chine Systems Inc Rob Zahensky
DESCRIPTION OF PARAMETERS
This parameter is used to set an extra amount of rigid tapping return. The tool is retracted
additionally near point R by the distance set in this parameter. If the tool has already been
retracted from rigid tapping, it will be retracted further only by the distance specified in
this parameter.
NOTE
If a negative value is set in this parameter, it is treated as a positive
value.
NOTE
When G code system A of the lathe system is used, it is specified
by an absolute method regardless of the setting of this parameter.
#2 D3R When Reset is done by reset operation or reset signal from PMC, 3-dimensional
coordinate system conversion mode and tilted working plane indexing mode is:
0: Canceled.
1: Not canceled.
#5 LV3 When system variables #100101 to #100132 (current position coordinates) and #100151
to #100182 (skip coordinates) are read in the 3-dimensional coordinate conversion mode
or tilted working plane indexing mode:
0: Coordinates of the workpiece coordinate system can be read.
1: Coordinates of the program coordinate system after 3-dimensional coordinate
conversion or tilted working plane indexing can be read.
This parameter applies also to system variables #5041 to #5060 (current position
coordinates) and #5061 to #5080 (skip coordinates).
#6 XSC The setting of a scaling magnification (axis-by-axis scaling) is:
0: Disabled.
1: Enabled.
#7 #6 #5 #4 #3 #2 #1 #0
5401
SCLx