Professional Documents
Culture Documents
Msds - Puriblends 1 6 Final 2018
Msds - Puriblends 1 6 Final 2018
Snaremosevej 27
7000 Fredericia
Version 3
May 3rd 2018
1.2 Relevant identified uses of the substance or mixture and uses advised against
Relevant identified uses: Adsorbent.
Uses advised against: Not applicable.
Reason why uses advised
Not applicable.
against:
Page 1 of 8
Section 2: Hazards identification
2.1 Classification of the substance or mixture
Classification according to
The product is not classified under the CLP regulation.
Regulation (EC) No 1272/2008
4.2 Most important symptoms and effects, both acute and delayed
Following inhalation: None known
Following skin contact: None known
Following eye contact: None known
Following swallowing: None known
Page 2 of 8
4.3 Indication of any immediate medical attention and special treatment needed
Not applicable.
Page 3 of 8
Section 7: Handling and storage
7.1 Precautions for safe handling
Avoid direct contact.
Protective measures: Avoid dust formation.
Use only in well-ventilated areas.
Measures to prevent fire: Not applicable
Page 4 of 8
(h) Evaporation rate Not applicable/determined
(i) Flammability (solid, gas) Not applicable/determined
(j) Upper/lower flammability or
Not applicable/determined
explosive limits
(k) Vapour pressure Not applicable/determined
(l) Vapour density Not applicable/determined
(m) Relative density 600-700 kg/m³
(n) Solubility(ies) Insoluble
(o) Partition coefficient: n-
Not applicable/determined
octanol/water
(p) Auto-ignition temperature Not applicable/determined
Page 5 of 8
Section 11: Toxicological information
11.1 Information on toxicological effects
Page 6 of 8
Section 13: Disposal considerations
13.1 Waste treatment methods
Recommendation: Disposal always according to local and national official regulations.
Product disposal: According to local and national official regulations.
Packaging disposal: As normal industrial waste.
14.7 Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code
No classification required
Page 7 of 8
Section 16: Other information
16.1 Other information
CAS: Chemical Abstracts Service (division of the American Chemical Society)
DNEL: Derived No-Effect Level (REACH)
LC50: Lethal concentration, 50 percent
LD50: Lethal dose, 50 percent
PBT: Persistent, Bioaccumulative and Toxic
vPvB: very Persistent and very Bioaccumulative
Abbreviations and acronyms:
EC(EINECS): European Inventory of Existing Commercial Chemical Substances
TRGS: Technische Regeln für Gefahrstoffe
LTEL: Long Term Exposure Limit
REACH: Registration, Evaluation, Authorisation and Restriction of Chemicals
CLP: Classification, Labelling and Packaging
STOT: Specific Target Organ Toxicity
Training advice: Substance should only be handled by trained operators
The above information describes exclusively the safety requirements of the product and is
based on our present-day knowledge. The information is intended to give you advice
about the safe handling of the product named in this safety data sheet, for storage,
Additional information: processing, transport and disposal. The information cannot be transferred to other
products. In the case of mixing the product with other products or in the case of
processing, the information on this safety data sheet is not necessarily valid for the new
made-up material.
-----end-----
Page 8 of 8