Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 1

III.

Directions: Write T if the statement is true


Republic of the Philippines and F, if it is false.
Department of Education
Caraga Region ____________1. Safety goggles must be worn anytime the
SCHOOLS DIVISION OF SURIGAO DEL SUR
power tools are being used in the work area.

4th Quarter Exam in TLE 8 Plumbing ____________2. Ear protection should be worn when
operating tools with high noise level.

I. MULTIPLE CHOICE. Encircle the letter of the ____________3. Loose clothing should be worn around
correct answer. when operating power tools. ____________4. The pockets
of pants are so designed to carry sharp tools thus preventing
damage to the cutting edge.
1. Figure having three sides and three angles.
a. Square b. triangle ____________5. The dust collection system is a large
vacuum that should only be operated at clean-up time.
c. circle d. rectangle
2. Flat, round figure formed by one curved line, all points of ____________6. Certain glues and most finishes are toxic.
which are equidistant from center point. Prolonged exposure to their fumes should be avoided.
a. Circle b. triangle
____________7. Used rags should be placed in the metal
c. parallelogram d. trapezoid container except when in use.
3. Figure with only one pair of parallel opposite sides.
____________8. Tools should be returned to their storage
a. Trapezoid b. parallelogram location after use. ____________9. When debris
c. circle d. square accumulates on the floor it should be put into the trash
4. Figure having four sides of equal length and four right container.
angles.
____________10. Mirror cuts and splinters need not be
a. Square b. rectangle reported to the teacher.
c. triangle d. circle
IV. Draw the correct symbols/ sign of the
5. Figure having no right angles and four sides of equal
following.
length.
a. Trapezoid b. rhombus 1. Gas pipe
2. Wall gang
c. circle d. square
3. Water meter
4. Cold water
II. Match Column A to Column B. 5. Water closet
6. Floor drain
COLUMN A COLUMN B 7. Vent line
8. Hot water
_____ 1. Long a. Very light line used to “block 9. Dish washer
Break Line in” an object. These lines are made 10. Lavatory
so light that little or no erasing is
_____ 2. needed. They serve as the base for
Dimension Line darkening in the permanent line. V. Convert the ff.
_____ 3. b. Heavy, solid line used to
Centerline frame in the drawing. 1. 50 cm to inches
c. A medium line used to show
_____ 4. Invisible edges and contours visible to the 2. 25 inches to cm
Line eye.
_____ 5. Visible d. A medium line used to show
Line edges and contours not visible to the
eye.
_____ 6. e. A light line used as axis of
Borderline symmetry. Used for center of circle
and and arcs, they symbol is shown.
_____ 7.
Construction Line
f. Light thin lines used to
show the sizes of the object.
Extension lights start about 1/16”
from visible or object line. The
dimension line is broken near the
center for the dimension.
g. Wavy line draws freehand
for the same purpose as long break.

You might also like