Professional Documents
Culture Documents
05621332D-SNAP 700 Upstacker Belt Change Instructions
05621332D-SNAP 700 Upstacker Belt Change Instructions
05621332D-SNAP 700 Upstacker Belt Change Instructions
Revision 0.0
21 August 2015
Page 1 of 8
Word Doc/SNAP 700/05621332D.doc
These are belt change instructions for an Up-Stacker 05628290.
Page 2 of 8
Word Doc/SNAP 700/05621332D.doc
Step 3: Loosen knobs holding label stack upright and remove upright.
Page 3 of 8
Word Doc/SNAP 700/05621332D.doc
Step 5: Remove hair pins and rivets that hold upper rollers in position. Rollers will come
off when rivets are removed.
Page 4 of 8
Word Doc/SNAP 700/05621332D.doc
Step 6: Remove center roller. Be careful not to lose bearings.
Step 7: Loosen but do not remove motor mount screws. With screws loose, remove guard
by sliding off.
Page 5 of 8
Word Doc/SNAP 700/05621332D.doc
Step 8: Remove stacker angle adjustment knob. Be careful to not lose washer.
Page 6 of 8
Word Doc/SNAP 700/05621332D.doc
Step 10: Flip pivot platform up and over top of base platform. Note both rollers, bearings
and O-Rings will fall off in this procedure.
Step 11: Remove O-Rings and replace with new. Reassemble by reversing procedure in
steps 1 through 10.
Page 7 of 8
Word Doc/SNAP 700/05621332D.doc
Revision History:
21/August/2015
Revision 0
Notes:
Page 8 of 8
Word Doc/SNAP 700/05621332D.doc