Professional Documents
Culture Documents
Lab-12-Control Conveyor by HMI and PLC - 1st2019
Lab-12-Control Conveyor by HMI and PLC - 1st2019
There are 2 sizes of product (small (B), big (A)), detecting by two sensors. Push Cylinder will push
Product A to box. There is sensor to count when product drops to box then it sends signal to HMI.
Step1: Press Start button to run conveyer belt and the Start light will be shown.
Case A: big product
Step2: Press Sensor High button and hold it then press Sensor Low button, it means that big one
is coming in. After that Push Cylinder will push product A into the box and conveyer belt will stop.
Step3: Press Counter Product A to count products. Then Push Cylinder will stop, and 7 segment
will show the counted number. Then conveyer belt will run again.
Step4: Repeat step2 again. If there is no product in the process about 1 min, the alarm will warn.
Case B: small product
Step2: Press Sensor Low button, it means the small product is coming in. Product B will drop into box.
Step3: Press Counter Product B to count products. Then 7 segment will show the counted number.
Step4: Repeat step2 again. If there is no product in the process about 1 minute, the alarm will warn.
2
01211323 Automation System and Components