Professional Documents
Culture Documents
Sis 2.0
Sis 2.0
Sis 2.0
PIP
Flash programming is a method of programming or updating the flash
file in the Electronic Control Module (ECM). Cat® Electronic Technician (ET) is used
-10
202 949
to flash program a file into the memory of the ECM.
3 / 2 2
For Work Area Vision System (WAVS) and Cat® Vision system with personnel
10: 0 1
3 /1
detect, display monitor is the camera monitor.
44:
46- 7
M0
Note: Customer versions of Cat ET are not capable of flash programming. Consult
119 03:0
your local Caterpillar Dealer for assistance.
©2 606 0
023
Use the "Flash File Search" tool on the Service Technician Workbench (STW) to
obtain the flash file for the machine. Alternatively, use the "Service Software Files"
Cat
feature on Cat® Service Information System (SIS) to obtain the flash file for the
erp
machine. Machine serial number or flash file part number is required to search for
illa
the flash file. After locating the correct flash file, download the flash file to a
r In
Personal Computer (PC). Note the name of the flash file for future reference.
c.
Table 1
Programmed
6. When the correct flash file is selected, Result: The flash
successfully.
press the "Open" button. programming was not
successful. Repair any
PIP
7. Verify that the "File Values" match the
application. If the "File Values" do not
active diagnostic or
event codes.
-10
match the application, obtain the correct
flash file. 202 949 Proceed to "WinFlash
10: 3 /0 2 2 1
Error Messages", Table
3 /1
8. When the correct flash file is selected,
44:
2.
press the "Begin Flash" button.
46- 7
M0
119 03:0
9. Cat ET will indicate when flash
©2 606
programming has been successfully
0
completed.
023
Cat
10. START the machine and check for
erp
proper operation. Repair any active
diagnostic or event codes. illa
r In
c.
Table 2
PIP-10949221
:
2023/03/17
10:43:25-03:00
i09640186
© 2023 Caterpillar Inc.
: