Professional Documents
Culture Documents
Router Table Inst
Router Table Inst
Congratulations on the purchase of your new Complete Basic Router Table Kit! It contains all the hardware
needed to assemble this full-size, full-featured router table. To make the assembly process easier to
understand and more enjoyable, please read the instructions fully before starting.
17
16
22
19
2 14
15
20
18 23
3 21 4
24
5 6
25
1
10
7
12
12
11
12
13
10
11 12
8 11
11
11
12
11
12
9
13
3. Slide one 5/16"-18 x 11⁄4" T-Bolt (11) into the 5. Insert the 5/16"-18 x 23⁄4" T-Bolts (13) through the holes
front-facing T-slot of each Adjustable MDF in the base of the Aluminum Fence Bracket (7) and
Fence Face (8). thread a 5/16"-18 T-Knob (10) on the end of each.
Quantity Quantity
15 Top Outer Leg Bracket 1 22 21⁄2" long 3/8"-16 TPI Hex Cap Bolt 2
16 Bottom Inner Leg Bracket 1 23 Large Washer 4
17 Bottom Outer Leg Bracket 1 24 3/8" Nylon Nut 2
18 Angled Leg Bracket Connector 1 25 #12 x 7/8" Table Mounting Screws 8
19 11⁄2" long 5/16"-18 TPI Hex Cap Bolt 8
20 Small Washer 16
21 5/16" Nylon Nut 8
2
Assemble the Leg Brackets
1. Insert the Bottom Inner Leg Bracket (16) into
the Top Inner Leg Bracket (14) and align the
predrilled holes.
Attach to the Table 2. Use the Insert Mounting Screws (6) to attach the
Plate Insert (3) to the Phenolic Plate (2).
1. Place the router table facedown on a blanket or other
soft surface to prevent scratching.
3. From underneath the Tabletop (1), install the Plate
Leveling Screws (5) in the predrilled holes at the
2. Turn the stand upside down and center it on the table
corners of the lipped opening for the plate.
side-to-side, with the outside edge of the rear mounting
flange 1/2" in from the back of the table.
4. Place the Phenolic Plate (2) in the lipped opening in
the Tabletop (1). Adjust the Plate Leveling Screws (5)
3. Mark the locations of the mounting holes. Remove
until the plate is flush with the table.
the stand.
Check Rockler.com for updates. If you have further questions, please
4. Drill 1/8" pilot holes at those locations, taking care not contact our Technical Support Department at 1-800-260-9663
to drill all the way through the table. or support@rockler.com
59133
Rev 05/14