Professional Documents
Culture Documents
New SDS-FoamSMART Standard PU Chemical (Part A)
New SDS-FoamSMART Standard PU Chemical (Part A)
New SDS-FoamSMART Standard PU Chemical (Part A)
Page 1 of 3
Section 2 – Composition
A liquid mixture of polyether/ polyester polyols, amine catalysts, water and surfactant
Inhalation: Remove casualty from exposure ensuring one’s own safety whilst doing so. If
unconscious, check for breathing and apply artificial respiration if necessary. If conscious,
ensure the casualty sits or lies down. Consult a doctor.
Skin: Remove any contaminated clothing and launder before re-use. Wash affected area with
soap and plenty of water.
Eye: Immediately wash with plenty of clear water or an eyewash solution for at least 15
minutes. Obtain medical attention.
Ingestion: If swallowed, do not induce vomiting, keep at rest, and seek prompt medical attention
Protective Equipment: Self-contained breathing apparatus and full protective clothing must be worn in fire
conditions
Personal Precautions: Remove all possible sources of ignition in the surrounding area.
Environmental Precautions: Do not discharge into drains or river. Contain the spillage using bunding.
Clean-up Methods: Ensure suitable personal protection during removal of spillage. Ventilate
area. Eliminate sources of ignition. Absorb spillage onto sand, earth or any
suitable absorbent material, and transfer to a container for disposal. Wash
the spillage area and clean with water and detergent. Do not allow entering
drains, sewer or water sources.
Disposal Operation: Disposal should be accordance with local, state or national legislation. The
generation of waste should be avoided or minimised wherever possible. If this is not
possible, destruction is to be in approved facility under controlled conditions.
This item is not classifies as non-hazardous and non-dangerous goods for transportation.
This item is not ICAO regulated
This item is not IATA regulated
None known
Other Information:
Section 16 – Other This safety data sheet is prepared in accordance with Commission Regulation (EU)
Information
No 453/2010.
The above information is believed to be correct but does not purport to be all inclusive and shall be used
only as a guide. This company shall not be held liable damage resulting from handling or from contact with
the above product. We therefore provide no warranty, either explicit or otherwise regarding the suitability of
our products for any applications. It is the responsibility of the user to ensure that any proprietary rights and
existing laws and legislation are observed