Professional Documents
Culture Documents
P.a.P.a. Installation Instruction 0120-0005-072018
P.a.P.a. Installation Instruction 0120-0005-072018
® TM
The P.A.P.A. is provided with a rubber connector on the II) Installation of a Maxi-Vent on top of the P.A.P.A. :
TM TM TM
1 2 3 ABS solvent;
c) wipe away any excess solvent to ensure this does
Rubber connector O-ring Male thread adapter
not get into the Maxi-Vent , as this will affect its
TM
operation;
b) 3 c)
a) 2
d) e)
1 1
a) 1 b)
75mm 110mm
k)
b) ensure the rubber connector is securely fitted to the base of the bottom-most
P.A.P.A. ;
TM
c) push-fit the rubber connector fitted to the base of this P.A.P.A. onto a
TM
e) remove the rubber connector fitted to the base of the next P.A.P.A. to be
TM
installed;
f) fit O-ring to the male thread adapter;
g) fit the male thread adapter to the base of this P.A.P.A. and glue into
TM
k) ensure the cap of the top P.A.P.A. is securely screwed in, or replace with
TM
g) 3
g) 3
a Maxi-Vent as described in II) overleaf.
TM
f) 2 f) 2
ensure the rubber connector is securely fitted to the base of the P.A.P.A. ;
TM
b) push-fit the rubber connector fitted to the base of the P.A.P.A. onto a 75mm or TM
c) into a 110mm 'T' pipe connection into the stack using a 45 degree 'T' joint on the
stack and a 45 degree bend to place the P.A.P.A. into a horizontal position -
TM
c)
45 angle
1
b)
1 1 support strut
b) b)
c) c)
75mm 110mm
For extra security it is recommended that
the P.A.P.A. is secured to an adjacent
TM