Professional Documents
Culture Documents
1 2 5 Cards TensionValve Saturated High
1 2 5 Cards TensionValve Saturated High
1.2.5
Problem
Solution
Reset Tension gain calibration to 1.
On the WFDD, click the calibration button.
- Enter 0 into High Calibrator and Measured value,
click Store High Setpoint button.
Yes Perform complete tension recalibration
- Enter 0 into Low Calibrator and Measured value, Done
procedure.
click Store Low Setpoint button.
- Enter 0 as User Zero Offset Adjust value,
click OK and exit.
Did it work?
No
No
Connect a short circuit across J16-R J16-S (at rear of WFMD). Check wiring from plug J16 up to
Is the tension now low? Yes Tension device. Repair if necessary. Done
Did it work? Swap tension device.
No
No
Copyright 2002