Professional Documents
Culture Documents
Phase Iv Welder Module 1.3
Phase Iv Welder Module 1.3
PHASE IV WELDER
Module 1.3
Weld Thin Gauge Carbon Steel Plate in the 4G Overhead Position (SMAW)
Module 1.3
Weld Thin Gauge Carbon Steel Plate in the 4G Overhead Position (SMAW)
WELDER HANDBOOK
Information Sheets 1
Exercise 3
Task Aid 7
October 2011
INFORMATION SHEET
Enabling Objective
Terminal Objective
1.3.1 Given SAEP-1112, E6010
Unaided, the welder will correctly weld thin gauge a n d E 7 0 1 8 we l d i n g
carbon steel plate in the 4g overhead position electrodes, welding tools,
(smaw). equipment, and materials.
Weld thin gauge carbon
steel plates in the 4G
introduction
overhead position in
In the previous module, you have learned how to accordance with SAEP-
prepare, set up and weld thin gauge carbon steel 321. Your finished work
plates in the 3G vertical position. The finished welds must meet the weld
were acceptable to visual standards SAEP-321. standards (visual and
x-ray) of SAEP-1112.
objective 1.3.1
introduction
EXERCISE
Directions: Using a correctly setup SMAW welding
machine, PPE, welding equipment, carbon steel electrodes, Your instr uctor will first
correctly prepared carbon steel plate 50mm × 150mm × demonstrate how to correctly
10mm; You will correctly weld thin gauge carbon steel plate weld thin gauge carbon steel
in the 4G position your finished work must meet SAEP-321 plate in the 4G overhead
inspection requirements. position.
OBJECTIVE
SAFETY REQUIREMENTS
TASK INTRODUCTION