Professional Documents
Culture Documents
Fbus-Hse/H1 LD: Features
Fbus-Hse/H1 LD: Features
FBUS-HSE/H1 LD
Fieldbus Network Module Linking Device
This document provides a quick guide to install and configure
the FBUS-HSE/H1 LD network module. For more detailed
information on using the network module, refer to the
FBUS-HSE/H1 Linking Device (LD) User Manual.
Features
• Foundation Fieldbus H1 interface to control network
• High Speed Ethernet interface
• Runs on 11 to 30 VDC power
• 0 to +55 °C operation
Installation
Complete the following steps to install the FBUS-HSE/H1 LD.
1. Use a flat-bladed screwdriver to open the DIN rail clip to the
unlocked position, as shown in Figure 1.
Rail Clip Locked Rail Clip Unlocked
3
1
2
5
3 3 3
System Requirements
A DHCP server in the network is required for the
FBUS-HSE/H1 LD to obtain its IP address and start up.
NC
NC
NC
NC
1 2 3 4 5
6 7 8 9
Data +
Data –
NC
NC
NC = No Connection
v v
v
11–30 VDC
+ V
backup power
supply – c c To adjacent device
c (optional connection)
(optional)
C
11–30 VDC +
primary power –
supply
107.19
[4.22]
109.5
[4.31]
91.44
[3.60]
Worldwide Support
National Instruments has offices located around the world to help
address your support needs. You can access our branch office Web
sites from the Worldwide Offices section of ni.com. Branch office
Web sites provide up-to-date contact information, support phone
numbers, email addresses, and current events.
If you have searched the technical support resources on our Web
site and still cannot find the answers you need, contact your local
office or National Instruments corporate. For telephone support in
the United States, dial 512 795 8248. For telephone support
outside the United States, contact your local branch office:
Australia 1800 300 800, Austria 43 0 662 45 79 90 0,
Belgium 32 0 2 757 00 20, Brazil 55 11 3262 3599,