Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

C ONV E R G E NC E A DJ US T ME NT F OC US A DJ US T ME NT

No. Adjus tment point A djus tment c onditions /proc edure Waveform or remarks No. Adjus tment point A djus tment c onditions /proc edure Waveform or remarks
1 C ONVE R G E NC 1. R eceive the " C ros s hatch P attern" s ignal. 1 F OC US 1. R eceive E -5C H (Monos cop pattern).
ADJ . 2. Us ing the remote controller, call NOR MAL mode. A DJ US T ME NT 2. With the remote controller, make the image nor-
( To be done mal.
after the purity ( S tatic c onvergenc e ) X axis 3. Adjus t the focus V R to make the character"575"
adjus tment.) 1. Overlap blue and red with the open-/clos ing an- on left bottom of monos cope as fine as pos s ible.
gle and rotation of the 4 pole magnet.
2. Overlap green on blue and red with the open-/
clos ing angle and rotation of the 6 pole magnet.
Y axis
( Dynamic c onvergenc e )
1. F ix the wedges in a pos ition s o that the deflection B R R B
york neck is at the center of top bottom and left
right. ( S traight line and without any blur horizon-
tal / vertical line).
2. Adjus t the R ed, B lue, upper and lower of the cen-
tre y axis on the screen by using the Volume (VR 2,
V R 1)at the deflection york. F ig. 1
(R efer to fig.1 and fig.2) Adjus t by V R 1
3. If the Horizontal R ed, B lue(X V ) on the s creen
B R R B
centre X axis is s hifted, correct the R ed, B lue (XV )
by adjus ting the balance coil on the deflection
york. (R efer to F ig. 3)
4. After confirm that there is no problems on the
entire s creen ,bond each wedge on C R T and
glas s tape on it. F as tening the s crews of DY and F ig. 2
magnet unit (purity , 4 - pole and 6 pole ), then Adjus t by V R 2
coat the lacquer paint on DY fas tening s crew and
magnet unit fas tening s crew.

12
B
Note: F ig. 3
In cas e of poor convergence adjus tment on the Adjus t by B alance C oil
top and bottom and of the s creen , adjus t DY by
s wing rightward and leftward.
(R efer to F ig-4)

F ig. 4
Adjus t by S wing DY

VR 1 6-P ole Magnet. C R T NE C K

VR 2
25mm ± 0.5mm
Lacquer
4-P ole Magnet
P urity Magnet
B alance C oil

12-1 12-2

You might also like