Professional Documents
Culture Documents
IO Card Replacement
IO Card Replacement
This section describes how to remove and replace the I/O modules.
The eight I/O module slots are enumerated as Slot 0 (on the left when viewed from the rear) through Slot 7. Ports on
an I/O
module are enumerated as 0 through 3, with 0 being on the bottom.
2. Enter the alerts show current or alerts show current-detailed command to display messages indicating I/O
failure. A sample output is shown.
3. Enter the enclosure show io-cards command to check the status of each I/O. Record the failed I/O. A sample output
is shown.
Steps
1. Align the module with the empty slot and carefully push the module into the slot.
Figure 3. Inserting the I/O module
2. When the I/O module appears to be seated, push and release the small button on the handle.
Check each I/O module LED. Each I/O module ejector handle contains a bi-colored LED. Green indicates normal
function, while
an amber color indicates a fault condition.
Steps
Enter the alerts show current command and confirm that the system has cleared the alert for the failed I/O module. It
may take one to two minutes after the I/O module replacement before the system clears the alert.