Professional Documents
Culture Documents
Tech Article - Motorised Changeover Connection Logic and Application
Tech Article - Motorised Changeover Connection Logic and Application
Tech Article - Motorised Changeover Connection Logic and Application
Connection logic
NC 1 NO 1 C1 C2 NO 2 NC 2
Control Accessories
A. Manual Control & Status Indication using Illuminated Push button assembly
B. AST Controller gives an option for controlling MCO through supply monitor
or manual control through Illuminated push button
C. Automatic sensing , measuring & controlling of MCO through smart AuxC
1000L controller
C-line Motorised Changeover Connection Logic & Application
Display Indicator
Display type LED Push Button LED Push Button 15 Status LED
display
Source (I,II) Available - Yes Yes
Indicator
Switch Position Yes Yes Yes
Unique Control Function
Default Priority - Yes Yes
Priority Source Swap - - Yes
Source Sensing Setting
Voltage sensing - Yes Yes
Under Voltage - Yes Yes
Over Voltage - Yes Yes
Frequency sensing - - Yes
Phase Loss - - Yes
Asymmetry - - Yes
Other
RS-232 - - Yes
Additional 12-48V DC Power - - Yes
Inputs
Generator Control Signal - - Yes
Output
Alarm (open and close commands of the - - Yes
Switch concerned are inhibited)
Auxiliary Contact - - Yes
Installation Flush Mounting Flush + Base Flush Mounting
Mounting
C-line Motorised Changeover Connection Logic & Application
Application
Reliable Changeover between either Earthing of equipment such as motors or
Primary and back up sources Signaling electrical lines and isolated load
in a fail-safe way
Source 1
Source 2
Source
Source
Soft Starter
Motor
Motor starter
Conventional
Happy Reading!!