Professional Documents
Culture Documents
Kimono Sleeve With Yoke
Kimono Sleeve With Yoke
90
BACK
*All values are given in cm.
45
This instruction is developed from the basic dress block, which is fitted to
the sleeve and the basic dress sleeve.
Before beginning this sleeve, place the alignment (bust dart) of the front
into the waist dart. You can move it later as needed.
You must also now decide whether to remove or keep the shoulder dart
on the back. In our illustration we have chosen to keep the shoulder dart.
Draw a line from the shoulder point on your sleeve that divides the sleeve
into two pieces. Be aware that this line is perpendicular to the bicep line. Shoulder
point
SIH
Instruction
WC
9
Start by drawing a right angle in the upper right side of the paper. The BACK
angle should be in a size so the pattern pieces can be placed along it as
shown in the figure. Then draw a guide line that divides the angle into two 9
equal parts (45 degrees).
BI
C
FRONT
match point, measure the remaining of both armholes. The value for
these measures is then inserted on the sleeve from the sleeve seams and
T
up along the sleeve cap on the side that belong to front and back respec-
ON
FR
tively. This is marked with the symbol O on the figure, which means equal
CF
SIH
length.
Place the pattern pieces onto the angle. Start by placing the back with CB
D
R
along one side of the angle and the sleeve so the line at the shoulder
ES
S
point lies along the 45-degree guide line. Make the match points on both
SL
EB
EE
armhole and sleeve cap to meet.
VE
Then place the front so CF is parallel to the angle and the match points
on both armhole and sleeve cap meet.
Connect the match points with a guide line. On front and back, draw a
new shoulder line along the shoulder and down to the guide line on the WC
sleeve where they meet and further downwards to the sleeve hem line.
- Note that you can benefit from cutting a bit of the shoulder height, to get
a neat rounded shoulder.
- Check also the length of the shoulder lines. They must have the same
length.
From the match points the yoke is drawn on front and back. From each
waist dart, draw a straight line up to the yoke.
The pattern pieces can now be copied. See the next page for the pattern
overview.
© CUT UP STUDIO 2017 Page 1 of 2
CB
C
BI
BACK SIDE PANEL
BACK
CF
YOKE / SLEEVE - FRONT
CB
SIH
EB
BI
C
FRONT
SIDE PANEL
EB
FRONT
WC WC
TV
CF
SIH
BP BP
WC WC