Download as pdf or txt
Download as pdf or txt
You are on page 1of 32

BLOCK DIAGRAM VHF AG

Presented by:
Galih Satria, S.Si, M.Sc

Contact
galih.btp@gmail.com
0816888884

BALAI TEKNIK PENERBANGAN - 2017


OUTLINE
 Blok Diagram Sistem Komunikasi
 Blok Diagram Transmitter
 Blok Diagram Receiver
 Blok Diagram VHF A/G Tower Set
Blok Diagram Sistem Komunikasi
Blok Diagram Transmitter
Prinsip Kerja Block Diagram TX
1. The oscillator generates the RF carrier at a preset frequency and maintains it within close
tolerances. Voltage and current delivered by the oscillator are weak. The oscillator outputs
must be amplified many times to be radiated any distance
2. The buffer stage or first intermediate power amplifier stage is a voltage amplifier that
increases the amplitude of the oscillator signal to a level that drives the power amplifier. The
other purposes is to isolate the oscillator from the amplifier stages. Without a buffer,
changes in the amplifier caused by keying or variations in source voltage would vary the load
of the oscillator and cause it to change frequency.
3. In the power amplifier a large amount of RF current and voltage is made available for
radiation by the antenna.
Prinsip Kerja Block Diagram TX
7. The microphone converts the audio frequency (AF) input (a person’s voice) into
corresponding electrical energy.
8. The driver amplifies the audio, and the modulator further amplifies the audio signal to the
amplitude necessary to fully modulate the carrier.
9. The output of the modulator is applied to the power amplifier. The pa combines the RF
carrier and the modulating signal in the power amplifier to produce the amplitude-
modulated signal output for transmission
10. In the absence of a modulating signal, a continuous RF carrier is radiated by the antenna.
Blok Diagram Transmitter
The power amplifier of a high-power transmitter
may require far more driving power than can be
supplied by an oscillator and its buffer stage. One
or more low-power intermediate amplifiers are
used between the buffer and the final amplifier
that feeds the antenna. The main difference
between many low- and high-power transmitters is
in the number of intermediate power-amplifier
stages used.
Blok Diagram Receiver
Prinsip Kerja Block Diagram RX
1. The Antenna of course receives the AM signal over the air waves.
2. The received AM signal is then feed to a low noise RF amplifier, which amplifies the signal.
An RF amplifier is a wide-band amplifier operating in the RF frequency range
3. A Local Oscillator is used within the AM receiver to generate a fixed frequency which is feed
to an RF mixer along with the amplified RF signal.
4. The IF carrier frequency is the difference frequency between the RF carrier frequency and
the local oscillator frequency [shown as Oscillator Wave]. The lower frequency IF signal is
used to reduce the complexity of the follow-on circuitry. The IF amplifier is again used to
amplify the signal, now at a lower frequency, which is then sent to the Detector.
Prinsip Kerja Block Diagram RX
5. The detector [or AM detector] is used to decode the signal envelope or amplitude
modulation from the incoming IF. Other names used for the detector include envelope
detector.
6. The audio signal this then input to an AF amplifier, or audio frequency amplifier. The Audio
Amplifier amplifies the signal to a point that will drive a speaker.
7. The Speaker changes electric signal to audio signal.
FUNGSI DASAR RX
Fungsi dasar RX :
1. Reception : Menerima sinyal yang
dipancarkan TX
2. Detection : Memisahkan sinyal
carrier dan sinyal informasi
3. Reproduction : Merubah sinyal
listrik menjadi gelombang suara
KARAKTERISTIK RX
1. Sensitivity : Kemampuan
menangkap sinyal yang lemah
kemudian dirubah.
2. Selectivity : Kemampuan untuk
menolak sinyal yang tidak
diinginkan
3. Noise Figure : jumlah noise /
gangguan yang dibawa oleh sinyal
4. Fadelity : kemampuan untuk
menerima sinyal informasi secara
utuh dan berkualitas
Blok Diagram Antenna
VHF AG

TX Unit RX Unit

AF AF + Control
Switch Over AF
Unit & Audio / Control
Control Unit
Interface

AF + Control
VHF –A/G Tower Set
 VHF Air Ground Tower Set adalah fasilitas komunikasi penerbangan yang
digunakan untuk komunikasi antar pesawat di udara dengan petugas
pengendali lalu lintas penerbangan di darat untuk keperluan pengaturan lalu
lintas penerbangan di suatu bandar udara yang pengaturanya dilakukan
dengan pengamatan secara visual.
 VHF Air Ground Tower Set merupakan sebuah kesatuan sistem peralatan
komunikasi penerbangan di menara pengawas lalu lintas penerbangan yang
terdiri dari beberapa system.
VHF Transmitter dan Receiver
 Merupakan peralatan yang berfungsi
untuk memancarkan dan menerima
gelombang elektromagnetik yang terdiri
dari pemancar dan penerima utama
(main) dan pemancar dan penerima
cadangan (standby).
 Dalam pengoperasiannya pemancar dan
penerima utama (main) dan pemancar
dan penerima cadangan (standby)
dihubungkan dengan pemindah otomatis
(Automatic change over switch) yang
dapat memindahkannya secara otomatis
sesuai dengan keperluan operasional.
SPECIFICATION
SPECIFICATION
Cavity Filter
Recorder
Recorder adalah peralatan elektronika
yang berfungsi untuk merekam semua
pembicaraan petugas Air Traffic
Service (ATC) dengan Pilot.
Console Desk
 Merupakan Meja kerja bagi petugas
pengendali lalu lintas udara yang
dilengkapi dengan berbagai peralatan
sehingga petugas dapat melakukan
control, monitor, dan koordinasi
sesuai dengan kebutuhan
operasional.
 Meja kerja juga dilengkapi dengan
peralatan yang sesuai dengan
kebutuhan agar pelayanan
pengendalian lalu lintas udara dapat
terlaksana
Remote Control Unit (RCU)
SPECIFICATION
Meteo System
 Merupakan peralatan yang berfungsi untuk mendapatkan informasi
meteorologi di sekitar tempat pemandu lalu lintas penerbangan berada,
sebagai data pembanding dari data informasi meteorologi yang bersumber dari
badan yang bertanggung jawab di bidang Meteorologi, Klimatologi dan
Geofisika.
WIND SENSOR
HUMIDITY & TEMPERATURE
PRESSURE
VSCS (Voice Switching Communication
System)
 VSCS merupakan perangkat
elektronik yang digunakan petugas
ATC untuk mengontrol dan
memonitor semua peralatan
komunikasi seperti radio, telepon,
interkom dan lain lain. Sehingga
petugas ATC dapat dengan mudah
dan tetap menggunakan satu
headset/ microphone
VSCS (Voice Switching Communication
System)
PENEMPATAN TOWER SET
PENEMPATAN TOWER SET
PENEMPATAN TOWER SET
PENEMPATAN TOWER SET

You might also like