Professional Documents
Culture Documents
HiT 7050 - Appunti
HiT 7050 - Appunti
HiT 7050 - Appunti
1
Connection to the equipment ( ITMN_E.pdf )
Obtain IP automatically
Obtain DNS server automatically
<Advanced>
….. “QST V2 Serial Line Channel” “QST V2 Serial Line NE” Properties
Q Interface connection
--------------------------------------------------------------------------------------------------------
1) If NE is in “read only” [on NE icon] < Access control > < Request write access >
2) Open NE < Module view > < NE/Subrack > < Configuratio > < Network Element >
[enter NE individual name] otherwise it cannot be set active.
3) Set NE to “Active” < NE State > < Set to Active > Reboot ……. loss of
communication Start NE
4) Set NE Date and Time < Module view > < NE subrack > < Configuration >
< NE Time >
5) Configure MCF Stack parameters < Module view > < MFP1 > < Configuration >
< MCF > < Stack parameters > < Configuration >
6) Switch NE to “Operation State” < NE state > < Set to Operation > Reboot?
8) Configure DCC < MPF1 > < Configuration > < MCF > < DCC > < Configuration >
[set as requested by Network Design]
9) Configure synchronization < MPF1 > < Configuration > < SEC >
[set as requested by Network Design]
10) Configure Modules < [module name] > < Configuration > < Card >
[set as requested by Network Design]
11) Configure Traffic < [Interface module view] > < [port symbol] > < Subvew >
< [traffic flow symbol] > < Configuration >
12) Back-Up / Restore < NE / Subrack > < Config DB management >
<Module view>
(on TAU4 / VC4 Mux) click dx < deactivate “VC4 Mux Structure” >
( if not already inactive )
(again in the same window, on TAU4 / VC4 Mux) click dx < Configuration >
(on TAU4 / VC4 Mux) click dx < activate “VC4 Mux Structure” >
DCC Activation and Configuration
Click dx < MFP1 > < MCF > < DCC > [ Only « 4 » DCC are available in hiT 7050 ]
Select one of the DCC Select the type of DCC ( DCCR – DCCM ) Select one
port of one of the SDH units < Connect >
Click dx < ”connected DCC” (the one hilyted) > < Configuration > In the
“Configuration” sector, select “Interface Type” [ User or Network ]
according to the LAPD necessary setting