Professional Documents
Culture Documents
EV 3.0 System User Guide
EV 3.0 System User Guide
0
Quick System Guide
32” 3D
Monitor 21” 2D
Monitor
2D Camera Holder
Keyboard
50L Insufflator
3D / 2D CCU
Digital Documentation
CO2
Gas Cylinder
Storage
A4 Thermal Sublimation
Printer
AESCULAP® 3D EinsteinVision® 3.0
System Set Up
(11)
* Attach scope with light lead, if
using standard camera head, prior
(10)
to White balance
• Start insufflator to commence insufflation (12)
AESCULAP® 3D EinsteinVision® 3.0
Flow 50 Insufflator
System Settings
Active Smoke Evacuation
Actual
Volume
& Reset
On / Off
Push light lead firmly into light aperture Press light source control to
(Do not rotate cable release) activate / Deactivate light output
Rotate clockwise to increase light output Rotate anti-clockwise to decrease light output
Light source illuminates with green ring around the rotation switch when activated (On)
White Balance
• 32” monitor delivers 3D images and 2D images, according to the signal sent to it, without
any need to change any settings on the monitor itself
• There is no need to make any changes to the monitor
• DO NOT MAKE ANY CHANGES TO THE MONITOR SETTINGS
There is a 3D/2D button on the monitor : DO NOT USE THIS BUTTON to swap between 3D and 2D