Professional Documents
Culture Documents
KKKL1103 Week 5 - (AutoCAD) Isometric Drawings-20191007042509
KKKL1103 Week 5 - (AutoCAD) Isometric Drawings-20191007042509
AutoCAD
Isometric drawing
At the end of this tutorial, you
will be able to:
• Learn another method to enter coordinates using
Direct Distance Entry (DDE).
• Draw isometric drawings using AutoCAD.
Direct Distance Entry (DDE)
DDE is a way of bypassing the usual ways of entering in
coordinates by just entering the distance.
Example:
3
Exercise 4.1
Draw an isometric drawing of the following
object:
4
Create new file using “acad.dwt” template file.
Type DDRMODES command and set as
follows:
7
Command: isoplane
Current isoplane: Left
Start
Enter isometric plane setting point
[Left/Top/Right] <Top>: left (Draw
counter-
Current isoplane: Left clockwise)
Command: line
Specify first point:
Specify next point or [Undo]: 1
Specify next point or [Undo]: 3
Specify next point or [Close/Undo]: 2
Specify next point or [Close/Undo]: 1.5
Specify next point or [Close/Undo]: c
8
Draw the top view of the box
Quick button to switch isoplane: F5
Switch to top isoplane by pressing F5.
AutoCAD will show <Isoplane Top>.
9
Start
point
Press F5
Command: <Isoplane Top>
Command: line
Specify first point:
Specify next point or [Undo]: 2
Specify next point or [Undo]: 1.5
Specify next point or [Close/Undo]: 2
Specify next point or [Close/Undo]: *Enter*
10
Draw the right side view of the box
Switch to right isoplane by pressing F5.
AutoCAD will show <Isoplane Right>.
11
Press F5
Command: <Isoplane Right>
Command: line
Specify first point:
Specify next point or [Undo]: 2
Specify next point or [Undo]: 1 Start
point
Specify next point or [Close/Undo]: 2
Specify next point or [Close/Undo]: *Enter*
12
Create the angle lines to
add the angled surface.
Turn off ORTHO for a
while.
13
Finish up by drawing the only circle in the picture.
Make sure you turn on back ORTHO.
Switch back to left isoplane by pressing F5.
Use ELLIPSE command, select isocircle to draw
the ellipse.
14
Press F5
Command: <Isoplane Left>
Command: ellipse
Specify axis endpoint of ellipse or
[Arc/Center/Isocircle]: i
Specify center of isocircle:
Specify radius of isocircle or
[Diameter]: d
Specify diameter of isocircle: 1
15
Exercise 4.2
R 0.5
17
Steps to draw an arc:
1) Command: ELLIPSE
2) Specify axis endpoint of ellipse or [Arc/Centre/Isocircle]: Arc
3) Specify axis endpoint of ellipse or [Arc/Centre/Isocircle]: Isocircle
4) Specify centre of isocircle:
5) Specify radius of circle or [Diameter]:
6) Specify start angle:
7) Specify end angle:
18
THANK YOU