Professional Documents
Culture Documents
34 Double Pulse Test Principle
34 Double Pulse Test Principle
– Principle
Double pulse test for IGBT/FWD
The 1st turn-on pulse
establishes desired current
value (e.g. Icnom for IGBT
characterization or 2xIcnom for
RBSOA test) in the inductive
load (inductor in the test).
Turn-off of the 1st pulse creates
current in free-wheeling diode
(FWD). Due to the high load
inductance and short turn-off
period, the load current is
almost constant in this interval.
The 2nd turn-on pulse results in
reverse recovery of the FWD
hence the current overshoot in
the test IGBT (like that in real
applications).
Vce overshoot at turn-off of the
2nd pulse should be kept below
IGBT blocking voltage (Vces).
22.05.2007 For internal use only Copyright © Infineon Technologies 2007. All rights reserved. Page 2
IGBT test schematic principle
22.05.2007 For internal use only Copyright © Infineon Technologies 2007. All rights reserved. Page 3
FWD test principle
22.05.2007 For internal use only Copyright © Infineon Technologies 2007. All rights reserved. Page 4
Dynamic Characteristics Test
Double Pulse Generator (DPG)
Load Inductor
15V Power Supply DC Bus System
Driver
Board
High Voltage Source
IGBT Module
22.05.2007 For internal use only Copyright © Infineon Technologies 2007. All rights reserved. Page 5
22.05.2007 For internal use only Copyright © Infineon Technologies 2007. All rights reserved. Page 6