Professional Documents
Culture Documents
Set C
Set C
1. When skinning a small wire, the insulation should be “pencil down” rather than cut square to
2. What type of hand tools commonly used in boring of ½ diameter hole in a panel board?
3. The technical term for the type THW wires should mostly is industrial wiring is
4. What do you call a fitting resembling a pipe with a removable cover across access to electric
conduit?
b. Condulet
5. An electrician should always have his tools in conditions, the most important reason is
6. Why is it necessary to use torque wrench in tightening bolted joints of Copper bus bars inside
bus ducts and bus ways?
7. What will you do if the load schedule reflects a 20AT/2.0 sq. mm. Lighting branch circuit of
which circuit breakers over rated?
d. Magnetic Lock
11. Part of the auxiliary system that set the motion-trigger action individually for each camera
d. Motion detection
12. The material used in long length bus bar joints to give allowance for thermal expansion is
b. Overload
c. Monitor
16. It is an over current protective device which opens (breaks) when there is an overcurrent in the
circuit.
b. Fuse
c. THHN
c. Alarm Bell
19. A Charging system producing 14.5 Volts with a current flow of 43.5 Amps, what is the circuit
resistance?
a. 0.33 amps
20. An outlet that supplies power for lamp and other plug-in devices
a. Receptacles
c. SPDT
a. SPST
23. A unit of measurement which describes the amount of electric current passing a certain point at
a particular time.
d. Ampere
a. Ohm
c. Voltmeter
27. An electrical device used to record the amount of electrical energy consumed by an appliance or
electrical system in a particular period of time.
a. Electric Meter
c. THHN
a. #8 AWG wire
30. Is a circuit conductor that carries current in normal operation, which is connected to ground (or
earth).
c. Neutral