Professional Documents
Culture Documents
Part-4 Important Question For B Gas Exams
Part-4 Important Question For B Gas Exams
Q-1 Dew point is defined as “the temperature at which the water vapour present in the Air
…………………………………………..”
a) Will evaporate
b) Will condense
c) Will dry
d) Will cause osmotic blisters
Q-2 As defined by National Grid / Transco, the “Engineer” is the person on site who is:
a) Appointed by a contractor and notified in writing to a client
b) Appointed by a client and notified to a contractor
c) Responsible for compiling site records
d) Delegates the compilation of site records to a contractor
Page 1 of 5
Q-5 when measuring: acidity and Alkalinity, distilled water has a pH value of
a) 1
b) 3.5 to 4.5
c) 7
d) 7.5 to 8.5
Q-6 Paint Systems: Properties and Performance Requirements, as detailed in PA9, paint testing is mostly
carried out according to which British Standard?
a) BS 729
b) BS 5493
c) BS 3900
d) BS 6072
Q-7 What are the total point system DFT requirements for the 2 preferred systems are in table SPA 1e
of PA10?
a) 255 and 225 microns
b) 265 and 235 microns
c) 265 and 225 microns
d) 255 and 235 microns
Q-8 Which British Standard covers the colour coding of pipe work?
a) BS 5493
b) BS 1710
c) BS 6072
d) BS 3900
Q-9 In accordance with PA 10 table SPA 3c, where T.S.A. or I.Z.S. have been used as the preferred
coating for surfaces operating above 340 degree Celsius
a) They should be cured by a chemical reaction
b) The coating must be immediately heated to 340º Celsius
c) They should be sealed with Polysiloxane inorganic coating
d) They must be farther protected by the application of silicone sealer
Page 2 of 5
Q - 10 Which of the following substrates are not dealt with in table SPA6 of PA 10?
a) Concrete
b) Stainless Steel
c) Galvanized Surfaces
d) They are all dealt with under that section
Q - 12 “Aerobic conditions” would refer to the highest proportion of which of the following?
a) Hydrogen
b) Oxygen
c) Nitrogen
d) Water
Q - 18 The correct voltage setting for a wet sponge detector over a coating with a DFT of 265µm is:
a) 9 volts
b) 67.5 volts
c) 90 volts
d) 125 volts
Q - 19 Most tips used on airless spray equipment are “Reversible” that is so that:
a) Tip life is prolonged
b) Costs can be kept down
c) Blockages can be cleaned
d) All of the above
Q - 20 What is the volume of paint required to cover a circular area of 15 meters radius if the material has
a specified “WFT of 176µm”?
a) 76.38 Liters
b) 124.40 Liters
c) 214.34 liters
d) 312.56 liters
Page 4 of 5
Answer: Volume = WFT x Area
1000
1000
Page 5 of 5