Professional Documents
Culture Documents
PLANNING AND QUALITY CONTROL - Exam Modality - Week 3 and 4
PLANNING AND QUALITY CONTROL - Exam Modality - Week 3 and 4
PLANNING AND QUALITY CONTROL - Exam Modality - Week 3 and 4
Question 1
Completed
Score 1.0 out of 1.0
Select one:
L(y)
y
k
t
Question 2
Completed
Score 1.0 out of 1.0
Select one:
Rate ofoutgoing heat - incoming heat rate = incoming heat rate =
outgoing heat rate - incoming heat rate = incoming heat rate = outgoing heat
rate = incoming heat rate change of the heat
content of the sensor
Rate of incoming heat + rate of outgoing heat = rate of
change of the heat
content in the sensor
Rate ofincoming heat - outgoing heat rate = heat input rate - rate of
change of the heat content of the sensor
Rate ofoutgoing heat - rate of change of heat content - rate of
change of heat content heat in the sensor
= Heat rate incoming
Select one:
Reduces variance in finished product characteristics
It applies primarily to parameters and other types of designs.
Determines the levels of controllable factors to minimize uncontrollable factors Determines the basic configuration of the
components
Question 4
Completed
Score 1.0 out of 1.0
Select one:
Some variables are under control, but other variables are not.
Uses noise factors to test the robustness of the system
A final round of confirmatory experiments is suggested.
All the interactions are studied and at the same time
Question 5
Completed
Score 1.0 out of 1.0
Within Taguchi's robust design, there are controllable factors. What is the characteristic of class IV factor?
Select one:
Affects only the average
Affects mean and variability
Only variability is affected
Does not affect the mean or variability
Select one:
|Natural Frequency
Linear input/output ratio
Transfer function
Exponential curve
Question 7
Completed
Score 1.0 out of 1.0
Select one:
Critical damping
Non-critical cushioning
Cushioned envelope
Damped sub
Question 8
Completed
Score 1.0 out of 1.0
What happens if the input signal u of an element suddenly changes from one value to another?
Select one:
The output signal θ will instantly change to its new value.
There is a decrease of energy in the element signal.
There is no significant change in the output signal.
The output signal θ will not change instantaneously to its new value.
In order to identify the transfer function G(s) of an element, what type of signals should be used?
Select one:
Unnormalized excitation signals
Standardized excitation signals
Audible low frequency signals
Any type of signal available
Question 10
Completed
Score 1.0 out of 1.0
Based on Taguchi's robust design (which is composed of 6 stages), please order the following 4 stages of the process leading from
innovation to customer
a) Product design
b) Manufacturing
c) Technology development
d) Process design
Select one: