Professional Documents
Culture Documents
Automatic Lights VW Polo
Automatic Lights VW Polo
Installation
5 - Press the two lower clips of the support of BCM; remove the BCM (down and forward).
6 - Insert adapter relays in (relays bracket) support of BCM.
7 - Release two clips of black cap connector A.
9 - Slide the two connector halves slightly to enter PIN 37 (clip) in its slot. Hear "click".
10 - Reinstall the black cap on the connector A.
11 - Reinstall the BCM. Press the two clips until you hear "click".
NOTE: If any of the cables is not available on the original connector its
slot in the red plug must remain vacant.
16 - Plug in the red and black connectors on the new wiring.
17 - Take the light switch connector 10 pin through the hole of the switch and plug in the new
switch AUTO lights.
18 - Install new light switch.
19 - Connect battery.
20 - Coding VCDS
Copy the specific New coding that I sent you for your POLO 6R and paste it.
For example:
You must check that all lights are working properly. Check one by one.
If you need to do the coding of your BCM for automatic lights, you can contact me by email or
PM.