Professional Documents
Culture Documents
Model Code&parts Num
Model Code&parts Num
The model primary ID that consists of the model name, prefix model code, transom length and serial
number is stamped on the label attached to the clamp bracket.
NOTE:
The serial number is a 7-digit sequential numbering scheme irrespective of model variation and tran-
som length.
Z 300 A ETO X
Output Model Transom height
Model category Model variation
horsepower generation (Drive shaft length)
Non: 2-stroke model Example: A Level 1: Starting system S (15”)
E: Enduro model 6 B M: Manual start L (20”)
F: 4-stroke model 9.9 C E: Electric start Y (22.5”)
L: Counter rotating model 75 D W: Electric start with manual start X (25”)
T: High thrust model 150 F U (30”)
D: Twin rotating propeller model 225 G Level 2: Control system
K: Kerosene model 300 H Non: Remote control without tiller
Z: HPDI model J handle
L H: Tiller handle
N C: Remote control with tiller handle
P
Q Level 3: Trim and tilt system
R Non: Manual tilt
S D: Hydraulic tilt
T P: PT(Power tilt)
U T: PT/T( Power trim & tilt)
V
X Level 4: Lubrication system
Y (2-stroke model)
(Repeat Non: Premixed fuel model
from A) O: Oil injection model
7-2