1. The document outlines the normal procedures for a Super King Air B200 aircraft, including checklists for preflight, before start, before taxi, before takeoff, climb, cruise, descent, approach, landing, after landing, and cruise power settings.
2. The procedures are broken down into steps listing items to check, settings to configure, and actions to take at different stages of flight.
3. Key items addressed include configuring fuel, switches, lights, pressurization, autopilot, flaps, trim, and engine instruments for takeoff, climb, cruise, descent, approach, and landing.
1. The document outlines the normal procedures for a Super King Air B200 aircraft, including checklists for preflight, before start, before taxi, before takeoff, climb, cruise, descent, approach, landing, after landing, and cruise power settings.
2. The procedures are broken down into steps listing items to check, settings to configure, and actions to take at different stages of flight.
3. Key items addressed include configuring fuel, switches, lights, pressurization, autopilot, flaps, trim, and engine instruments for takeoff, climb, cruise, descent, approach, and landing.
1. The document outlines the normal procedures for a Super King Air B200 aircraft, including checklists for preflight, before start, before taxi, before takeoff, climb, cruise, descent, approach, landing, after landing, and cruise power settings.
2. The procedures are broken down into steps listing items to check, settings to configure, and actions to take at different stages of flight.
3. Key items addressed include configuring fuel, switches, lights, pressurization, autopilot, flaps, trim, and engine instruments for takeoff, climb, cruise, descent, approach, and landing.
PREFLIGHT CLIMB 0. Fuel and Payload SET 1. Landing Gear UP 1. Elevator Trim SET FOR TAKEOFF 2. Flaps UP 2. Brakes SET 3. Yaw Damp ON 3. Switches OFF 4. Climb Power SET 4. Landing Gear Lever DOWN 5. Propeller 1800 RPM 5. Power Leavers IDLE 6. Propeller Synchronizer ON 6. Propeller Leavers FULL FOWARD 7. Auto feather OFF 7. Condition Leavers CUT OFF 8. Engine Instruments MONITOR 8. Cabin Sign FSB NO SMOKING 9. Taxi and Landing Lights OFF 9. Cabin Temp Mode OFF 10. Cabin Sign AS REQUIRED 10. Vent Blower AUTO 11. Cabin Pressurization CHECK 10. Electric Heat OFF 12. Ice Vanes CLOSED 13. Engine Auto Ignition OFF BEFORE START 1. Battery Switch ON CRUISE 2. Fuel Quantity CHECK 1. Cruise Power SET 3. DC Volt/Loadmeter CHECK 2. Engine Instruments MONITOR 4. Stall Warning TEST 3. Auxiliary Fuel Gauge MONITOR 5. Annunciator Lights TEST DESCENT 6. Beacon Light ON 1. Cabin Pressurization SET BEFORE TAXI 2. Cabin Sign AS REQUIRED 1. Loadmeters CHECK 3. Windshield Anti-Ice AS REQUIRED 2. Avionics master ON 4. Power AS REQUIRED 3. Lights AS REQUIRED TRANSITION LEVEL 4. Cabin Temperature AS REQUIRED 5. Altimeter SET QNH 5. Instruments CHECKED APPROACH 6. Ice Vanes OPEN 1. Pressurization CHECK BEFORE TAKEOFF 2. Cabin Sign ON 1. Avionics CHECK 3. Auto feather Switch ARM 2. Pressurization CHECK SET 4. Flaps APPROACH 3. Autopilot SET 5. Landing Gear DOWN 4. Trim tabs CHECK POS 6. Landing and Taxi Lights AS REQUIRED 5. Flaps SET AND CHECK 7. Propeller Synchronizer OFF 6. Flight controls CHECK 8. Engine Auto Ignition ON 7. Rudder Boost ON 9. Ice Vanes OPEN 8. Auto feather ARM 10. Altimeter CHECK 9. Bleed air Valve OPEN LANDING 10. Annunciator panel EXTINGUISHED 1. Flaps DOWN 11. Ice protection AS REQUIRED 2. Yaw Damp OFF 12. Engine Auto Ignition ON 3. Propeller Levers FULL FORWARD 13. Standby Attitude ERECT AFTER LANDING LINE UP 1. Landing and Taxi Lights AS REQUIRED 1. Transponder ALT 2. Ice Protection OFF 2. Compass/HDG SET 3. Engine Auto-Ignition OFF 3. Landing/Strobe Lights ON 4. Electrical Load OBSERVE LIMITS 5. Trim SET 6. Flaps UP Revision Date: 20 SET 23 SUPER KING AIR B200 NORMAL PROCEDURES PAGE 1