Professional Documents
Culture Documents
Captura de Tela 2023-08-04 À(s) 15.11.40
Captura de Tela 2023-08-04 À(s) 15.11.40
Captura de Tela 2023-08-04 À(s) 15.11.40
0634
Electrical data Features
Note: 1)
With a di/dt of 100 A/µs.
page 1/3
070808/9 LEM reserves the right to carry out modifications on its transducers, in order to improve them, without prior notice. w w w .lem.com
Current Transducer LT 2005-S
Isolation characteristics
Application examples
Safety
When operating the transducer, certain parts of the module can carry hazardous
voltage (eg. primary busbar, power supply).
Ignoring this warning can lead to injury and/or cause serious damage.
This transducer is a built-in device, whose conducting parts must be inaccessible
after installation.
A protective housing or additional shield could be used.
Main supply must be able to be disconnected.
page 2/3
070808/9 LEM reserves the right to carry out modifications on its transducers, in order to improve them, without prior notice. w w w .lem.com
Dimensions LT 2005-S (in mm. 1 mm = 0.0394 inch)
Left view
Hall sensor position
Front view
Connection
Top view
• General tolerance ± 0.5 mm • IS is positive when IP flows in the direction of the arrow.
• Transducer fastening 4 holes ∅ 8.5 mm • Temperature of the primary conductor should not exceed
4 M8 steel screws 100°C.
Recommended fastening torque 10 Nm or 7.38 Lb - Ft • This is a standard model. For different versions (supply
• Octagonal primary through-hole voltages, turns ratios, unidirectional measurements...),
for bar 60.5 x 20.5 mm please contact us.
or ∅ maxi 56 mm
• Connection of secondary M5 threaded studs
Recommended fastening torque 2.2 Nm or 1.62 Lb - Ft
page 3/3
070808/9 LEM reserves the right to carry out modifications on its transducers, in order to improve them, without prior notice. w w w .lem.com