Professional Documents
Culture Documents
Manual-Wireless Keypad
Manual-Wireless Keypad
. The units are designed to ensure battery life equivalent to an estimated 2000 transmissions.
lnstallation Screw
Hole
@m¡m
@@m
Figure 1 Figure 2
F¡gure 3 Figure 4
1 .Use a flat-blade screwdriver to pry the panel out of the hole. (Fig.'l )
2.Use a Phillips screwdriver to remove the two 2x7 screws to separate the board of w¡reless keypad.
(F¡g.2-3)
3.Secure the cover to the wall w¡th two 4X25 countersunk head tapping screws. (Fig.4)
l. Method of use
The use of the keypad is based on i.e. numbers of from 1 to 9 digits that the user is required to key in by
Channel 1 initial password: 1'1. Enter the password 11, press .( button to confirm.
Channel 2 initial password: 33. Enter the password 33, press > button to confirm.
2. Changing a password:
Channel l:1) Pressthe < button till you hear the long beep, the signal light in the u pper left corner flashes.
a. Long beep & the signal light stop flash means the old password is correct.
b. Rapid beep means the old password is wrong and exit password update.
3) Enter the password with l-8 digits, press the < button to confirm, the signal Iight in the
lower left corner flashes.
a. Rapid short beep means the password exceeds I digits and exit password update.
4) Enterthe new password again, press the { button to confirm.
a- Long beep & the s¡gnal light stop flash means the old password is correct.
b. Rap¡d beep means the old password is wrong and exit password update-
3) Enter the password with 1-8 digits, press the ) button to confirm, the signal light in the
lower Ieft corner flashes.
a. Rap¡d short beep means the password exceeds I d¡g¡ts and exit password update.