Professional Documents
Culture Documents
Sampa Axle Rod Catalogue
Sampa Axle Rod Catalogue
Sampa Axle Rod Catalogue
GROUP
2019
PRODUCTS GROUP
AXLE ROD
3
1
9. Press down the bushing using drift (1) and counterhold (2)
until it is low enough to expose the entire snap ring groove.
10. Press the snap ring down into the groove.
11. Fit the V-rod, see the section on fitting
4
8. Remove the bolts which hold the V-rod to the rear axle. 4. Remove the snap ring using, for example, two screwdrivers. ATTENTION !
Do not use grease or oil on the snap ring.
7. Press the bushing down using drift (1) and press drift (3)
so that the outer edge of the bushing is flush with the V-rod.
1) Clean the V-rod. 8) Check the condition of the bearing journal for corrosion and
B 2) Fix the V-stay plate in a vice.
A wear.
Note: Do not grip the guide flanges on the underside!
Note: If the bearing journal is corroded, the V-stay should be
3) Remove the rubber boot clamps. Release the boot from replaced.
the centre joint and fixing plate.
9) Press on the ball with drift (2) so that the bush is compressed.
C Remove the circlip and washer.
ATTENTION ! 2
Make sure to follow the instructions to avoid
personal injury or damage to product or equipment. Note: Tighten bolts the cross
10) Remove the plastic ring, ball and bush using an M14 x 1.5 x
130 fully threaded bolt.
4. Remove the V-stay.
5. Clean the contact surface and the centring hole.
6. Refit the cable clamps on the V-stay.
Specifications:
A 275±45 Nm
B 310±35 Nm
A
1. Place trestles under the rear axle.Raise the frame with the 1
air spring and trestle the rear frame.
2. Remove the propeller shaft between the shaft axles using
sleeve. Place a jack underneath the companion flange.
Note: New screws and nuts
Specifications:
A 160±23 Nm
Instructions of V Arm Assembly Instructions of V Arm Assembly
12) Lubricate the new ball and bush with grease from the spares kit. 18) Fill with grease around the centre joint from the tube V-Rod, Centre Joint, Overhaul 5) Connect the bolts or pin on the bolt channels of central joint.
Apply grease in the groove around the bush. included in the kit.
1) Clean the V-rod.
14) Place the ball and bush in the V-stay (with the threaded part 19) Clean the grease from the fixing plate bearing journal and
towards the ball). Press the ball and bush with drift (3). The drift from the conical ball hole, very thoroughly. 6) Fit a 5 tonnes hydraulic cylinder, with dowel (A), in the puller
shall press the ball and bush down at the same time until they for the centre joint. Fit hydraulic pump (B) to the hydraulic
bottom in the V-stay, so that the circlip can be fitted. Make sure 20) Fit the rubber boot around the fixing plate. Fit a new clamp 2) Remove the cover bolts cylinder.
that the circlip locates properly in the groove. around the rubber boot. The clamp is located straight from the
side. Tighten the clamp with pliers.
21) Fit the V-stay to the fixing plate. Use a M14 x 1.5 bolt,
tensile strength 10.9 or higher. Tighten the bolt to a torque of 7) Pull the centre joint out from the dowel on the attachment
200 Nm. Then remove the bolt. Fit the new bolt supplied with plate. Remove the puller from the hydraulic cylinder and
the repair kit. Tighten to a torque of 135±10 Nm. 3) Remove the mounting plate hydraulic pump.
15) Fit the plastic ring and washer in place. Press down with drift (4).
8) Knock out the centre joint from the V-stay using mandrel
4
4
Specifications:
200 Nm 135±10 Nm
22) Fit the bellows around the centre joint. Fit a new clamp 9) Remove the rubber bellows and fit new bellows.
16) Fit the circlip and press on it with drift (5). Release pressure
around the boot, the clamp is placed straight from the side.
slightly so that the circlip locates in the groove. The circlip opening
Tighten the clamp with pliers. Note: Be careful with the placing of the rubber bellows,
shall be located 90 degrees with respect to the V-stay arms. Make
4) Remove the rubber dust cap. see illustration.
sure that the circlip locates properly in the groove by striking it with
a drift and hammer.
10) Clean the housing where the centre joint will be fitted.
Check the V-stay housing for damage, cracks, burrs,etc
ATTENTION !
17) Fix the V-stay plate in a vice.
Make sure to follow the instructions to avoid
Note: Do not grip the guide flanges on the underside! personal injury or damage to product or equipment.
Instructions of V Arm Assembly Definition of Dimension
11) Prepare the press table for the hydraulic press. Note: Only use new clamps.
12) Place the V-stay level in the press. 17) Replace the rubber dust cap.
Note: Make sure the lock ring in the centre joint faces
towards the side where the cover will be fitted.
13) Press in the new centre joint using hollow mandrel The
outer ring must bottom against the flange.
øA x øA1 / B
19) Torque tighten.
Specifications:
77 ±7 Nm
Specifications:
8 ±1,5 Nm
ATTENTION !
Make sure to follow the instructions to avoid personal injury or
øA x øA1 / B d / øE x C
damage to product or equipment.
Definition of Dimension
d / øE x C øA x øA1 / B
øA x øA1 / B d / øE x C
dxl dxm øD x S
SUITABLE FOR
MERCEDES
sampa.com
Suitable for Mercedes
V Arm
V Arm 095.241
Replaces Suitable for
942 350 15 05 950 ACTROS
952 ACTROS
375 350 00 05
954 ACTROS
942 350 10 05 930 ACTROS 2/3
947 350 10 05 932 ACTROS 2/3
934 ACTROS 2/3
947 350 01 05
940 AXOR 2
944 350 00 05 944 AXOR 2
950 AXOR 2
954 AXOR 2
957 ECONIC
L: 622 mm
Replaces Replaces
000 350 22 05 000 350 23 05
ø75xø25/130 ø85xø25/152
Description 200.002
Bracket
Rear
Replaces
947 325 19 09
947 325 02 09
162x257x140
095.255 V Arm
L: 761,7 mm
Replaces Replaces
000 350 20 05 000 350 21 05
ø67xø23/130 ø75xø25/152
200.002 Description
Bracket
Rear
Replaces
947 325 19 09
947 325 02 09
162x257x140
V Arm 095.256
Replaces Suitable for
948 350 23 05 950 ACTROS
952 ACTROS
948 350 09 05
953 ACTROS
954 ACTROS
930 ACTROS 2/3
932 ACTROS 2/3
933 ACTROS 2/3
934 ACTROS 2/3
964 AROCS
942 AXOR 2
943 AXOR 2
374 AXOR 2
L: 667 mm
Replaces Replaces
000 350 28 05 000 350 29 05
ø85xø25/130 ø108xø25/152
Replaces Replaces
948 423 05 33 947 325 19 09
948 423 01 33 947 325 02 09
161x435x205 162x257x140
095.276 V Arm
L: 622 mm
Replaces Replaces
000 350 45 05 000 350 49 05
000 350 52 05
ø75xø25/130 ø100xø25/152
Bracket Bracket
Rear
Replaces Replaces
947 325 19 09 942 325 03 09
947 325 02 09
162x257x140 -
V Arm 095.277
Replaces Suitable for
942 350 12 05 954 ACTROS
934 ACTROS 2/3
942 350 08 05
963 ACTROS MP4
942 350 05 05 964 ACTROS MP4
960 350 01 05 964 ANTOS
964 AROCS
375 350 05 05
375 AXOR
944 AXOR 2
954 AXOR 2
374 AXOR 2
L: 622 mm
Replaces Replaces
- 000 350 44 05
000 350 51 05
ø85xø23/130 ø85xø25/152
Description 202.351
Bracket
Replaces
942 325 03 09
095.278 V Arm
L: 622 mm
Replaces Replaces
000 350 45 05 000 350 44 05
000 350 52 05 000 350 51 05
ø75xø25/130 ø85xø25/152
Bracket Bracket
Rear
Replaces Replaces
947 325 19 09 942 325 03 09
947 325 02 09
162x257x140 -
V Arm 095.280
Replaces Suitable for
948 350 22 05 950 ACTROS 944 AXOR 2
952 ACTROS 374 AXOR 2
948 350 17 05
953 ACTROS 958 AXOR 2
954 ACTROS
930 ACTROS 2/3
932 ACTROS 2/3
933 ACTROS 2/3
934 ACTROS 2/3
964 AROCS
940 AXOR 2
942 AXOR 2
943 AXOR 2
L: 621,5 mm
Replaces Replaces
000 350 37 05 000 350 36 05
000 350 42 05
ø85xø23/130 ø108xø25/152
Replaces Replaces
947 325 19 09 942 325 03 09
947 325 02 09
162x257x140 -
095.373 V Arm
L: 667 mm
Replaces Replaces
000 350 37 05 000 350 36 05
000 350 42 05
ø85xø23/130 ø108xø25/152
Bracket Bracket
Rear
Replaces Replaces
947 325 19 09 942 325 03 09
947 325 02 09
162x257x140 -
V Arm 095.406
Replaces Suitable for
948 350 29 05 930 ACTROS 2/3
932 ACTROS 2/3
933 ACTROS 2/3
934 ACTROS 2/3
964 AROCS
940 AXOR 2
942 AXOR 2
943 AXOR 2
944 AXOR 2
374 AXOR 2
L: 622 mm
Replaces Replaces
000 350 45 05 000 350 49 05
000 350 52 05
ø75xø25/130 ø100xø25/152
Replaces Replaces
947 325 19 09 942 325 03 09
947 325 02 09
162x257x140 -
095.407 V Arm
L: 622 mm
Replaces Replaces
000 350 45 05 -
000 350 52 05
ø75xø25/130 ø85xø25/152
Bracket Bracket
Rear
Replaces Replaces
947 325 19 09 942 325 03 09
947 325 02 09
162x257x140 -
V Arm 095.419
Replaces Suitable for
948 350 27 05 930 ACTROS 2/3
932 ACTROS 2/3
933 ACTROS 2/3
934 ACTROS 2/3
964 AROCS
940 AXOR 2
942 AXOR 2
943 AXOR 2
944 AXOR 2
374 AXOR 2
958 AXOR 2
L: 625 mm
Replaces Replaces
000 350 37 05 000 350 36 05
000 350 42 05
ø85xø23/130 ø108xø25/152
Replaces Replaces
948 423 05 33 947 325 19 09
948 423 01 33 947 325 02 09
161x435x205 162x257x140
095.279 V Arm
L: 622 mm
Replaces Replaces
000 350 47 05 000 350 46 05
ø67xø23/130 ø75xø25/152
095.475 V Arm
L: 622 mm
Replaces Replaces
000 350 48 05 000 350 44 05
000 350 33 05 000 350 51 05
ø85xø23/130 ø85xø25/152
V Arm 095.340
Replaces Suitable for
613 333 01 04 613 TOURISMO
356 333 13 04
613 333 00 04
L: 507 mm
Description 010.676
Repair Kit
2 pieces
Replaces
000 350 10 05
ø67xø15/115
V Arm 095.341
Replaces Suitable for
658 350 02 05 385 NG
620 NG
656 350 00 05
623 NG
616 NG
655 SK
658 SK
656 SK
657 SK
L: 622 mm
Replaces Replaces
000 350 18 05 000 350 17 05
ø85x21/26x152 M24x1,5/ø108x68
095.1096 V Arm
L: 622 mm
Replaces Replaces
000 350 48 05 000 350 44 05
000 350 33 05 000 350 51 05
ø85xø23/130 -
095.1095 V Arm
L: 625 mm
V Arm 095.476
Replaces Suitable for
960 350 04 05 963 ACTROS MP4
964 AROCS
960 350 34 05
L: 568 mm
L: 585 mm
Description 010.575
Repair Kit
Replaces
000 350 30 05
000 350 06 13
000 586 11 35
ø85xø21/152
L: 579 mm
010.576 Description
Repair Kit
Replaces
000 350 04 13
000 586 12 35
ø95xø21/152
L: 500 mm
Replaces Replaces
000 350 02 13 000 586 15 33
000 586 14 33
000 350 05 05
000 350 03 05
ø80xø21/152 ø80
L: 565 mm
Replaces Replaces
000 350 27 05 948 325 49 09
948 325 04 09
ø85xø21/152 199x353x145
Replaces Replaces
948 325 12 09 948 325 42 09
948 325 23 09
948 325 10 09
- ø21/182x125/458,5
L: 850 mm
010.674/1 Description
Repair Kit
Replaces
000 330 14 11
ø67xø17/100
L: 635 mm
010.576 Description
Repair Kit
Replaces
000 350 04 13
000 586 12 35
ø95xø21/152
L: 755 mm
Description 010.674/1
Repair Kit
Replaces
000 330 14 11
ø67xø17/100
L: 658 mm
Description 010.578
Repair Kit
Replaces
000 350 05 06
000 330 06 11
ø85xø19/130
L: 750 mm
010.578 Description
Repair Kit
Replaces
000 350 05 06
000 330 06 11
ø85xø19/130
L: 630 mm
020.541 Description
Repair Kit
Replaces
000 350 15 13
ø85xø19/130
L: 579 mm
Description 010.575
Repair Kit
Replaces
000 350 30 05
000 350 06 13
000 586 11 35
ø85xø21/152
L: 845 mm
Description 010.674/1
Repair Kit
Replaces
000 330 14 11
ø67xø17/100
L: 615 mm
010.698 Description
Repair Kit
Replaces
000 350 27 05
ø85xø21/152
L: 629 mm
010.576 Description
Repair Kit
Replaces
000 350 04 13
000 586 12 35
ø95xø21/152
L: 664 mm
Description 020.541
Repair Kit
Replaces
000 350 15 13
ø85xø19/130
L: 754 mm
Replaces Replaces
000 330 14 11 000 331 00 17
ø67xø17/100 ø77xø24x96
L: 655 mm
204.244 Description
Rubber Bushing
Replaces
972 350 09 06 S
ø77xø17/115
L: 579 mm
010.575 Description
Repair Kit
Replaces
000 350 30 05
000 350 06 13
000 586 11 35
ø85xø21/152
L: 813 mm
Replaces Replaces
000 330 14 11 974 330 01 07 S
ø67xø17/100 ø76xø20,5x119
L: 951 mm
Description 010.674/1
Repair Kit
Replaces
000 330 14 11
ø67xø17/100
L: 925 mm
010.674/1 Description
Repair Kit
Replaces
000 330 14 11
ø67xø17/100
L: 860 mm
204.206 Description
Rubber Bushing
Replaces
960 330 01 07 S
ø70xø17x100
L: 585 mm
Description 010.698
Repair Kit
Replaces
000 350 27 05
ø85xø21/152
L: 522 mm
Replaces Replaces
000 350 19 05 000 350 30 05
000 350 06 13
000 586 11 35
M24x1,5/ø95x72 ø85xø21/152
L: 532 mm
Replaces Replaces
000 350 22 05 960 350 09 06 S
ø75xø25/130 ø85xø21/130
L: 532 mm
060.635 Description
Repair Kit
Replaces
960 350 07 06
960 350 13 06
ø75xø21/130
L: 600 mm
ø87xø17/130
ø74,5xø21/130
ø75xø17/130
ø75xø19/130
ø67xø19/130
950
952
ACTROS
ACTROS
Repair Kit 000 350 24 05 010.672
953 ACTROS
954 ACTROS
930 ACTROS 2/3
932 ACTROS 2/3
933 ACTROS 2/3
934 ACTROS 2/3
940 AXOR 2
942 AXOR 2
ø100xø25/152
671
357
CONECTO
O 405
Repair Kit 000 330 26 11 010.685
000 330 25 11
612 O 405
671 O 345
ø56xø15/90
950
952
ACTROS
ACTROS
Repair Kit 000 350 25 05 010.687
953 ACTROS
954 ACTROS
930 ACTROS 2/3
932 ACTROS 2/3
933 ACTROS 2/3
934 ACTROS 2/3
940 AXOR 2
942 AXOR 2
ø75xø25/130
ø75x19/28x126
950
952
ACTROS
ACTROS
Repair Kit 000 350 34 05 010.694
000 350 32 05
953 ACTROS
954 ACTROS 629 330 04 07
930 ACTROS 2/3
932 ACTROS 2/3
933 ACTROS 2/3
934 ACTROS 2/3
375 AXOR
375 AXOR 2
ø75xø25/130
950
952
ACTROS
ACTROS
Repair Kit 000 350 31 05 010.695
953 ACTROS
954 ACTROS
930 ACTROS 2/3
932 ACTROS 2/3
933 ACTROS 2/3
934 ACTROS 2/3
950 AXOR 2
952 AXOR 2
ø85xø25/152
ø100xø25/152
ø85xø19/130
ø108xø25/152
ø85xø23/130
ø75xø15/115
382
357
OH SERIES
O 405
Repair Kit 000 330 07 07 020.524
000 330 27 11
382 O 500
382 O 500 U / 1725 / 59
628 CITARO
ø75xø17/115
368
382
OH SERIES
O 500
Repair Kit 000 330 20 11 020.546
382 O 500 M / 1728
382 O 500 R / 1830 / 30
382 O 500 M / 1725
382 O 500 M / 1725 / 1726
382 O 500 U / 1725 / 59
634 O 500
634 O 500 RSD / 2736/8X2/30
628 CITARO
ø75xø19/130
ø67xø17/115
382
382
OH SERIES
O 500
Repair Kit 000 350 09 06 040.573
382 O 500 R / 1830 / 30
382 O 500 M / 1725 / 1726
382 O 500 U / 1725 / 59
634 O 500
634 O 500 RSD / 2736/8X2/30
ø85xø19/130
ø75xø19/115
ø67xø17/115
M24x1,5/ø95x72
M24x1,5/ø95x72
M36x1,5/ø85x171
M39x1,5/ø85x172,5
M36x1,5/ø85x248
M39x1,5/ø80x162,5
ø80
387
393
NG
NG
621
617
NG
NG
Repair Kit 000 350 04 05 010.536
000 586 01 35
383 NG 619 NG
381 NG 616 NG 000 586 18 33
385 NG 645 NG 000 586 19 33
380 NG 646 NG
389 NG 648 NG
620 NG 647 NG
623 NG 655 SK
622 NG 658 SK
M24x1,5/ø90x62
652
651
MK
MK
Repair Kit 000 350 02 05 010.554
000 586 10 35 S
653 MK
654 MK
383 NG
381 NG
385 NG
380 NG
617 NG
619 NG
M20x1,5/ø80x46
652
651
MK
MK
Repair Kit 000 350 14 05 010.633
With Bolt
653 MK
654 MK
655 SK
658 SK
656 SK
657 SK
ø80x21/26x152
652
651
MK
MK
Repair Kit 000 350 15 05 010.634
653 MK
654 MK
655 SK
658 SK
656 SK
657 SK
M24x1,5/ø90x60
M24x1,5/ø90x57,5
M24x1,5/ø90x59
254x354,5x155,5
Type: 1
Dimensions
Sampa No. OEM No. Description Type Applications
A (mm) B (mm)
102.509 000960 018145 Hexagon Head Screw M18x1,5 80 1 L SERIES - NG/SK/MK SERIES - UNIMOG
102.508 000000 000643 Hexagon Head Screw M18x1,5 160 1 ATEGO - ATEGO 2 - O 405 - LKN SERIES
102.508 000960 018081 Hexagon Head Screw M18x1,5 160 1 ATEGO - ATEGO 2 - O 405 - LKN SERIES
102.141 308765 020014 Hexagon Head Screw M20x1,5 150 1 ACTROS - ATEGO - ATEGO 2 - NG - SK - MK SERIES
102.141 000960 020093 Hexagon Head Screw M20x1,5 150 1 ACTROS - ATEGO - ATEGO 2 - NG - SK - MK SERIES
102.466 942 990 02 01 Hexagon Head Screw M20x1,5 180 1 NG - SK - MK SERIES - UNIMOG
102.466 000960 020122 Hexagon Head Screw M20x1,5 180 1 NG - SK - MK SERIES - UNIMOG
Type: 1 Type: 2
Dimensions
Sampa No. OEM No. Description Type Applications
A (mm) B (mm)
102.507 308765 020016 Hexagon Head Screw M20x1,5 240 1 AXOR 2 - ACTROS - AXOR - NG/SK/MK SERIES
102.507 000960 020080 Hexagon Head Screw M20x1,5 240 1 AXOR 2 - ACTROS - AXOR - NG/SK/MK SERIES
102.502 000000 005503 Hexagon Head Screw M24x2 180 1 ACTROS - AXOR 2 - ACTROS 2/3
102.502 308765 024011 Hexagon Head Screw M24x2 180 1 ACTROS - AXOR 2 - ACTROS 2/3
020.146 910105 014011 Hexagon Bolt With Flange M14x1,5 50 2 AXOR 2 - ATEGO 2 - ACTROS 2/3
102.481 000000 005548 Hexagon Bolt With Flange M16x1,5 55 2 AXOR 2 - ATEGO 2 - ACTROS 2/3
102.481 910105 016018 Hexagon Bolt With Flange M16x1,5 55 2 AXOR 2 - ATEGO 2 - ACTROS 2/3
102.482 000000 005544 Hexagon Bolt With Flange M16x1,5 70 2 AXOR 2 - ATEGO 2 - ACTROS 2/3
102.482 910105 016014 Hexagon Bolt With Flange M16x1,5 70 2 AXOR 2 - ATEGO 2 - ACTROS 2/3
102.473 910105 016008 Hexagon Bolt With Flange M16x1,5 90 2 ACTROS - AXOR 2 - ATEGO 2 - CITARO
102.479 000000 005292 Hexagon Bolt With Flange M16x1,5 100 2 CONECTO - TOURO
102.479 910105 016009 Hexagon Bolt With Flange M16x1,5 100 2 CONECTO - TOURO
200.408 000000 005547 Hexagon Bolt With Flange M16x1,5 160 2 ACTROS - AXOR 2 - ACTROS 2/3 - TOURO
200.408 910105 016017 Hexagon Bolt With Flange M16x1,5 160 2 ACTROS - AXOR 2 - ACTROS 2/3 - TOURO
102.522 000000 005563 Hexagon Bolt With Flange M18x1,5 50 2 TRAVEGO - TOURISMO - INTEGRO
102.522 910105 018022 Hexagon Bolt With Flange M18x1,5 50 2 TRAVEGO - TOURISMO - INTEGRO
102.524 000000 005723 Hexagon Bolt With Flange M18x1,5 55 2 AXOR 2 - CONECTO
102.524 910105 018023 Hexagon Bolt With Flange M18x1,5 55 2 AXOR 2 - CONECTO
102.475 002 990 35 22 Hexagon Bolt With Flange M18x1,5 60 2 TRAVEGO - TOURO - TOURISMO - CONECTO
200.449 000000 005564 Hexagon Bolt With Flange M18x1,5 60 2 ACTROS - AXOR 2 - ATEGO - ATEGO 2
200.449 910105 018024 Hexagon Bolt With Flange M18x1,5 60 2 ACTROS - AXOR 2 - ATEGO - ATEGO 2
102.478 910105 018025 Hexagon Bolt With Flange M18x1,5 65 2 AXOR 2 - ATEGO 2 - ACTROS 2/3
102.478 000000 005693 Hexagon Bolt With Flange M18x1,5 65 2 AXOR 2 - ATEGO 2 - ACTROS 2/3
102.480 012 990 76 01 Hexagon Bolt With Flange M18x1,5 70 2 TRAVEGO - TOURISMO
102.477 910105 018027 Hexagon Bolt With Flange M18x1,5 80 2 AXOR 2 - ATEGO 2 - ACTROS 2/3
102.487 000000 005725 Hexagon Bolt With Flange M18x1,5 90 2 AXOR 2 - ACTROS 2/3
102.487 910105 018028 Hexagon Bolt With Flange M18x1,5 90 2 AXOR 2 - ACTROS 2/3
102.488 910105 018029 Hexagon Bolt With Flange M18x1,5 100 2 AXOR 2 - ACTROS 2/3
102.476 000000 005567 Hexagon Bolt With Flange M18x1,5 120 2 TRAVEGO - TOURISMO - CITARO
102.474 000000 005568 Hexagon Bolt With Flange M18x1,5 130 2 CITARO - TRAVEGO
102.485 000000 005569 Hexagon Bolt With Flange M18x1,5 140 2 AXOR 2 - ACTROS - ACCELO - TOURO
102.485 910105 018033 Hexagon Bolt With Flange M18x1,5 140 2 AXOR 2 - ACTROS - ACCELO - TOURO
102.486 000000 005396 Hexagon Bolt With Flange M18x1,5 160 2 CONECTO - TOURO - TOURISMO - TRAVEGO
Type: 2 Type: 3
Dimensions
Sampa No. OEM No. Description Type Applications
A (mm) B (mm)
102.523 000000 005575 Hexagon Bolt With Flange M20x1,5 90 2 TOURISMO - INTEGRO
102.523 910105 020026 Hexagon Bolt With Flange M20x1,5 90 2 TOURISMO - INTEGRO
102.519 000000 005729 Hexagon Bolt With Flange M20x1,5 100 2 AXOR 2 - ACTROS - TOURINO
102.519 910105 020027 Hexagon Bolt With Flange M20x1,5 100 2 AXOR 2 - ACTROS - TOURINO
200.447 910105 020035 Hexagon Bolt With Flange M20x1,5 260 2 AXOR 2 - ATEGO 2 - ACTROS 2/3
200.447 000000 005731 Hexagon Bolt With Flange M20x1,5 260 2 AXOR 2 - ATEGO 2 - ACTROS 2/3
200.302 000000 005732 Hexagon Bolt With Flange M20x1,5 278 2 AXOR 2 - ACTROS 2/3
200.302 910105 020036 Hexagon Bolt With Flange M20x1,5 278 2 AXOR 2 - ACTROS 2/3
102.489 006 990 85 04 Hexagon Bolt With Flange M24x2 100 2 AXOR 2
102.520 014 990 10 01 Hexagon Bolt With Flange M24x2 120 2 ACTROS - ACTROS 2/3 - AXOR 2
202.169 000000 005464 Lock Nut M24x2 23,5 3 ACTROS 2/3 - AXOR 2 - ATEGO 3
202.169 308674 024000 Lock Nut M24x2 23,5 3 ACTROS 2/3 - AXOR 2 - ATEGO 3
sampa.com
Suitable for Man
V Arm
V Arm 095.208
Replaces Suitable for
81.43270.6076 TGA
E Series
81.43270.6078
F 2000
81.43270.6034 F 90
81.43270.6030 F 90 Unterflur
16…
81.43270.6054
19…
81.43270.6057 22…/24…
81.43270.6082
81.43270.6074
81.43270.9076
L: 621 mm
Replaces Replaces
81.95301.6133 81.95301.6132
81.43270.6083 81.43270.6080
81.43270.6122
81.43270.6071
81.43270.6084
ø90xø23/152 M24x1,5/ø90x59
V Arm 095.208/1
Replaces Suitable for
81.43270.6078 S TGA
E Series
81.43270.6034 S
F 2000
81.43270.6030 S F 90
81.43270.6054 S F 90 Unterflur
16…
81.43270.6055 S
19…
81.43270.9054 S 22…/24…
81.43270.9078 S
L: 621 mm
Replaces Replaces
- 81.95301.6132
81.43270.6080
81.43270.6122
81.43270.6071
81.43270.6084
ø95xø23/152 M24x1,5/ø90x59
095.233 V Arm
L: 627 mm
Replaces Replaces
81.43270.6126 81.95301.6132
81.43270.6118 81.43270.6080
81.43270.6122
81.43270.6071
81.43270.6084
ø85xø23/130 M24x1,5/ø90x59
095.281 V Arm
L: 627 mm
Replaces Replaces
81.43270.6105 81.95301.6132
81.43270.6080
81.43270.6122
81.43270.6071
81.43270.6084
ø85xø25/130 M24x1,5/ø90x59
V Arm 095.360
Replaces Suitable for
81.43270.6053 ECM
E Series
81.43270.9053
M 2000 L
M 2000 M
M90
F 90 Unterflur
14…
18…
L: 693 mm
Replaces Replaces
81.43270.6091 81.43270.6065
ø75xø19/115 M20x1,5/ø72x46
V Arm 095.369
Replaces Suitable for
81.43270.6145 TGS
TGX
81.43270.6146
TGA
82.43270.6005
82.43270.6007
82.43270.1601
81.43270.6147
L: 622 mm
Replaces Replaces
81.43270.6145 S 82.43270.0001
81.43270.6146 S
ø75xø24x130 M24x1,5/ø90x59
095.394 V Arm
L: 627 mm
Replaces Replaces
81.43270.6079 81.95301.6132
81.43270.6080
81.43270.6122
81.43270.6071
81.43270.6084
ø95xø23/152 M24x1,5/ø90x59
095.479 V Arm
L: 627 mm
Replaces Replaces
- 81.43270.6139
81.43270.6101
81.43270.6109
M24x1,5/ø95x72 ø85xø25/152
V Arm 095.273
Replaces Suitable for
81.43270.6150 TGS
TGX
81.43270.6137
TGA
81.43270.6116 F 2000
81.43270.6151 22…
81.43270.6167
81.43270.6175
L: 627 mm
Replaces Replaces
81.43270.6105 81.43270.6110
ø85xø25/130 ø100xø25/152
Description 021.480
Bracket
Replaces
81.43240.0127
095.296 V Arm
L: 627 mm
Replaces Replaces
81.43270.6105 81.43270.6110
ø85xø25/130 ø100xø25/152
021.480 Description
Bracket
Replaces
81.43240.0127
V Arm 095.272
Replaces Suitable for
81.43270.6097 TGS
TGX
81.43270.6113
TGA
81.43270.6135
81.43270.6160
81.43270.6161
81.43270.6165
81.43270.6173
L: 627 mm
Replaces Replaces
- 81.43270.6139
81.43270.6101
81.43270.6109
ø75xø23/130 ø85xø25/152
V Arm 095.477
Replaces Suitable for
81.43270.6102 TGS
TGX
81.43270.6106
TGA
81.43270.6108
81.43270.6170
81.43270.6162
L: 578,6 / 713 mm
Replaces Replaces
81.43270.6111 81.43270.6105
ø75xø23/130 ø85xø25/130
095.478 V Arm
L: 643 mm
Replaces Replaces
- 81.43270.6129 S
81.43270.6130 S
81.43270.6131 S
81.43270.6169 S
ø75xø19/115 ø85xø25/152
095.480 V Arm
L: 643 mm
Replaces Replaces
81.43270.6138 81.43270.6139
81.43270.6101
81.43270.6109
ø75xø19/115 ø85xø25/152
V Arm 095.481
Replaces Suitable for
81.43315.6037 LION'S COACH
LION'S REGIO
81.43315.6036
LION'S STAR
SUE / UEL
JETLINER
SKYLINER
CITYLINER
STARLINER
TOURLINER
TRENDLINER
18…/24…/26…
L: 782 mm
Replaces Replaces
81.43270.6133 81.43315.0009
ø85xø21/130 ø95xø19/145
L: 572 mm
Description 020.556
Repair Kit
Replaces
81.43220.6285
ø85xø25/130
L: 571 mm
020.501 Description
Repair Kit
With Bolt
Replaces
81.43220.6108
81.43220.6132
81.43220.6109
81.43220.6290
81.43220.6415
ø72xø19/130
L: 571 mm
020.545 Description
Repair Kit
Replaces
81.43220.6108 S
ø72xø19/130
L : 596 mm
Description 020.502
Repair Kit
With Bolt
Replaces
81.43230.6043
ø80xø19/130
L: 590 mm
Description 010.578
Repair Kit
Replaces
81.43220.6107
81.43220.6055
81.43220.6104
81.43220.6073
ø85xø19/130
L: 565 mm
Replaces Replaces
81.43220.6107 83.43240.0500
81.43220.6055 81.43240.0099
81.43220.6104
81.43220.6073
ø85xø19/130 -
L: 596 mm
020.541 Description
Repair Kit
Replaces
81.43220.6250
81.43220.6369
ø85xø19/130
L: 500 mm
Description 020.502
Repair Kit
With Bolt
Replaces
81.43230.6043
ø80xø19/130
L: 585 mm
Description 020.543
Repair Kit
Replaces
81.96401.0152
ø95xø19x130
L: 414 mm
020.555 Description
Repair Kit
With Bolt
Replaces
81.43220.6322
ø72xø23/130
L: 572 mm
020.546 Description
Repair Kit
Replaces
85.43220.6002
ø75xø19/130
L: 531 mm
Description 010.578
Repair Kit
Replaces
81.43220.6107
81.43220.6055
81.43220.6104
81.43220.6073
ø85xø19/130
L: 572 mm
Description 020.672
Repair Kit
Replaces
81.43220.6398 S
81.43220.6268 S
81.43220.6274 S
81.43220.6291 S
81.43220.6292 S
ø75xø19/130
L: 941 mm
040.503 Description
Repair Kit
Replaces
-
ø67xø17/115
L: 750 mm
010.578 Description
Repair Kit
Replaces
81.43220.6107
81.43220.6055
81.43220.6104
81.43220.6073
ø85xø19/130
L: 622 mm
Description 020.541
Repair Kit
Replaces
81.43220.6250
81.43220.6369
ø85xø19/130
L: 630 mm
Replaces Replaces
81.43220.6107 81.43220.6204
81.43220.6055
81.43220.6104
81.43220.6073
ø85xø19/130 M24x2/ø95x74
L: 566 mm
020.501 Description
Repair Kit
With Bolt
Replaces
81.43220.6108
81.43220.6132
81.43220.6109
81.43220.6290
81.43220.6415
ø72xø19/130
L: 596 mm
020.501 Description
Repair Kit
With Bolt
Replaces
81.43220.6108
81.43220.6132
81.43220.6109
81.43220.6290
81.43220.6415
ø72xø19/130
L: 614 mm
Description 010.578
Repair Kit
Replaces
81.43220.6107
81.43220.6055
81.43220.6104
81.43220.6073
ø85xø19/130
L: 570 mm
Description 010.578
Repair Kit
Replaces
81.43220.6107
81.43220.6055
81.43220.6104
81.43220.6073
ø85xø19/130
L: 330 mm
Replaces Replaces
81.43220.6177 S1 81.43220.6177 S
81.43220.6179 S1 81.43220.6179 S
81.43220.6224 S1 81.43220.6224 S
M16x1/83,5xø67,5 ø67,5xø15/80
L: 330 mm
020.166 Description
Rubber Bushing
Replaces
81.43220.6177 S1
81.43220.6179 S1
81.43220.6224 S1
M16x1/83,5xø67,5
L: 644 mm
Description 020.501
Repair Kit
With Bolt
Replaces
81.43220.6108
81.43220.6132
81.43220.6109
81.43220.6290
81.43220.6415
ø72xø19/130
L: 694 mm
Description 020.501
Repair Kit
With Bolt
Replaces
81.43220.6108
81.43220.6132
81.43220.6109
81.43220.6290
81.43220.6415
ø72xø19/130
L: 585 mm
030.559 Description
Repair Kit
Replaces
81.43220.6241
ø95xø21/130
L: 596 mm
020.546 Description
Repair Kit
Replaces
85.43220.6002
ø75xø19/130
L: 572 mm
Description 020.546
Repair Kit
Replaces
85.43220.6002
ø75xø19/130
L: 777 mm
Description 020.524
Repair Kit
Replaces
81.43230.6051
81.43230.6068
81.43270.6064
ø75xø17/115
L: 660 mm
020.674 Description
Repair Kit
Replaces
81.43220.6326
ø67xø17/100
L: 470 mm
020.165 Description
Rubber Bushing
Replaces
81.43220.6177 S
81.43220.6179 S
81.43220.6224 S
ø67,5xø15/80
L: 633 mm
Replaces Replaces
81.43220.6107 81.43220.6204
81.43220.6055
81.43220.6104
81.43220.6073
ø85xø19/130 M24x2/ø95x74
L: 661 mm
Description 020.601
Repair Kit
Replaces
81.43220.6315
ø67xø19/130
L: 413 mm
020.165 Description
Rubber Bushing
Replaces
81.43220.6177 S
81.43220.6179 S
81.43220.6224 S
ø67,5xø15/80
L: 531 mm
TGS
TGX
Rubber Bushing 81.43722.0085 020.329
81.43722.0077
TGA
18…
ø24,5xø96/95
LION'S CLASSIC
LION'S COACH
Rubber Bushing 81.96210.0447 020.158
LION'S STAR
SG
SL
UEL
18…
22…/24…
24…
28…
ø94xø19/130
LION'S CITY
LION'S CLASSIC
Repair Kit - 010.575
SG
SL
18…
24…
28…
ø85xø21/152
SG
SL
Repair Kit 81.43270.6040 010.576
81.43270.6045
SR
SUE
R Series
ø95xø21/152
EL
ND
Repair Kit 81.43230.6061 010.668
NG
NGT
NL
NM
NMT
12…/14…
18…/24…
ø75xø19/130
ø67xø17/100
ø85xø21,5/26x129
ø85xø21/130
ø80xø19/130
ø67xø15/100
ø75xø19/115
ø90xø23/152
ø85xø25/152
ø85xø19/130
TGS
TGX
Repair Kit 81.43270.6123 020.670
TGA
ø85xø23/130
TGS
TGX
Repair Kit 81.43270.6124 020.675
TGA
TGM
E Series
F 2000
22…
ø85xø25/130
TGS
TGX
Repair Kit 81.43270.6125 020.676
TGA
TGM
E Series
F 2000
22…
ø95xø21/152
ø67xø19/115
TGS
TGX
Repair Kit 81.43220.6244 040.570
TGA
ø75xø17/115
LION'S CITY
LION'S CLASSIC
Repair Kit 81.43270.6127 040.573
LION'S COACH
LION'S REGIO
LION'S STAR
SL / SUE
SKYLINER
CITYLINER
STARLINER
TOURLINER
ø85xø19/130
ø75xø23/152
ø90xø23/152
ø20xø46x60
M24x1,5/ø90x59
M24x1,5/ø90x60
Dimensions
Sampa No. OEM No. Description Type Applications
A (mm) B (mm)
102.533 06.01284.3350 Hexagon Head Screw M12x1,75 50 1 TGS / TGX / TGA / TGL / TGM
102.533 06.01284.7321 Hexagon Head Screw M12x1,75 50 1 TGS / TGX / TGA / TGL / TGM
102.525 06.01494.4612 Hexagon Head Screw M18x1,5 65 1 TGS / TGX / TGA / TGM / F 2000 / E Series
102.447 06.01494.4718 Hexagon Head Screw M18x2 95 1 TGS / TGX / TGA / TGM / F 90 / F 2000 / E Series
102.438 06.01493.4719 Hexagon Head Screw M18x2 100 1 TGA / F 90 / F 2000 / E Series / Lion's / Neoplan
102.438 87.01114.0711 Hexagon Head Screw M18x2 100 1 TGA / F 90 / F 2000 / E Series / Lion's / Neoplan
102.446 06.01499.0173 Hexagon Head Screw M18x2 105 1 TGS / TGX / TGA / F 90 / F 2000 / E Series
102.446 06.01499.0025 Hexagon Head Screw M18x2 105 1 TGS / TGX / TGA / F 90 / F 2000 / E Series
102.448 06.01493.4721 Hexagon Head Screw M18x2 120 1 TGA / F 90 / F 2000 / E Series / M 90 / M 2000
102.448 87.01114.0730 Hexagon Head Screw M18x2 120 1 TGA / F 90 / F 2000 / E Series / M 90 / M 2000
102.449 06.01493.4722 Hexagon Head Screw M18x2 130 1 TGS / TGX / TGA / F 90 / F 2000 / E Series
102.449 87.01114.0712 Hexagon Head Screw M18x2 130 1 TGS / TGX / TGA / F 90 / F 2000 / E Series
102.440 06.01494.6724 Hexagon Head Screw M18x2 150 1 TGS / TGX / TGA / TGM / F 2000 / E Series
102.440 06.01494.4724 Hexagon Head Screw M18x2 150 1 TGS / TGX / TGA / TGM / F 2000 / E Series
102.528 06.01494.4725 Hexagon Head Screw M18x2 160 1 TGS / TGX / TGA / F 90 / E Series
102.641 06.01494.4726 Hexagon Head Screw M18x2 170 1 TGS / TGA / Lion's City / Centroliner
102.441 06.01493.4740 Hexagon Head Screw M18x2 210 1 F 90 / F 2000 / E Series / 26…/30…/32…/34…
102.441 06.01493.4730 Hexagon Head Screw M18x2 210 1 F 90 / F 2000 / E Series / 26…/30…/32…/34…
102.527 06.01493.4733 Hexagon Head Screw M18x2 240 1 TGA / F 90 / F 2000 / E Series / Lion's
102.527 87.01114.0725 Hexagon Head Screw M18x2 240 1 TGA / F 90 / F 2000 / E Series / Lion's
102.437 06.01494.4734 Hexagon Head Screw M18x2 250 1 TGS / TGX / TGA / TGM / F 2000 / E Series
102.531 06.01733.4921 Hexagon Head Screw M20x2 80 1 F 90 / F 2000 / E Series / Lion's City / Lion's Classic
102.530 06.01493.4925 Hexagon Head Screw M20x2 160 1 F 90 / F 2000 / E Series / Lion's City / Lion's Star
102.435 81.90001.0414 Hexagon Head Screw M24x2 130 1 TGS / TGX / TGA / TGM / F 2000 / E Series
102.534 06.02816.1518 Hexagon Bolt With Flange M22x1,5 65 2 TGS / TGX / TGA
102.436 06.02202.1013 Hexagon Bolt With Flange M20x2 75 2 TGS / TGX / TGA / TGM / E Series / F 2000
102.436 06.02202.5013 Hexagon Bolt With Flange M20x2 75 2 TGS / TGX / TGA / TGM / E Series / F 2000
Socket Head Bolt With
102.535 81.90030.0146 M18x2 35 3 TGS / TGX / TGA / F 90 / F 2000 / E Series
Flange
sampa.com
Suitable for Volvo
V Arm
V Arm 095.231
Replaces Suitable for
1080690 F10
F12
1606200
F16
1576952 FL10
6886777 FL12
N10
1509222
N10 USA
N12
N12 USA
NL10 BR
NL12 BR
L: 636 mm
Replaces Replaces
1080690 S 273706
276191
ø95xø23/152 M24x1,5/ø90x59
V Arm 095.249
Replaces Suitable for
20367004 FH12
FH16
20741703
FL6
20507262 FMX
20741695 FM12
FM9
22318833
NH12
L: 662,4 mm
Replaces Replaces
20547286 20741710
3093544
ø75xø19/115 M20x1,5/ø72x46
095.282 V Arm
L: 671 mm
Replaces Replaces
20840815 20840820
3093630 S
3093631 S
ø85x21/26x130 M14x1,5/ø90x60
095.283/SD V Arm
L: 662 mm
Replaces Replaces
20523294 20557378
ø84x18/21x115 ø45xø75x43
V Arm 095.336
Replaces Suitable for
3172829 FL12
FL6
8073569
NH12
L: 680 mm
Replaces Replaces
3092452 20741710
3093544
ø75x17/20x115 M20x1,5/ø72x46
V Arm 095.337
Replaces Suitable for
20382314 FL12
FL6
20502944
1094466
L: 549 mm
Replaces Replaces
3092452 20741710
3093544
ø75x17/20x115 M20x1,5/ø72x46
095.362 V Arm
L: 644 mm
Replaces Replaces
271187 3133173
11043031
ø75xø17/115 M20x1,5/ø72x46
095.368 V Arm
L: 651 mm
Replaces Replaces
20864587 20864583
ø108xø23/165 M14x1,5/ø90x36/50
V Arm 095.392
Replaces Suitable for
22318834 FH12
FH16
21295227
FM9
FM12
NH12
L: 671 mm
Replaces Replaces
21295230 20840820
ø85xø23/130 M14x1,5/ø90x60
V Arm 095.413/SD
Replaces Suitable for
22238525 FH12
FH16
20589061
FM12
FM9
FH Series
FM Series
L: 662 mm
Replaces Replaces
21196270 22238527
21196275
ø86xø20/115 M12x1,75/ø75x43
095.482 V Arm
L: 760 mm
Replaces Replaces
20740700 -
20753761
24426061
22445499
ø75xø17/130 M24x1,5/ø108x68
095.240 V Arm
L: 687,5 mm
Replaces Replaces
1598588 20554908
3159435 3173759
1075255
1591689
ø91,5x150 M16x2/ø138,5x96
V Arm 095.257
Replaces Suitable for
20556493 FH12 J
FL6
3173297
8156997
L: 676,4 mm
Replaces Replaces
1628107 20554908
3173759
1075255
1591689
ø91,3x170 M16x2/ø138,5x96
V Arm 095.258
Replaces Suitable for
3173293 FH12
FH16
20556492
FM10
1628135 FM12
8156993 FM7
L: 660,3 mm
Replaces Replaces
1628107 20554908
3173759
1075255
1591689
ø91,3x170 M16x2/ø138,5x96
095.259 V Arm
L: 677,3 mm
Replaces Replaces
1628107 20554908
3173759
1075255
1591689
ø91,3x170 M16x2/ø138,5x96
095.260 V Arm
L: 666,3 mm
Replaces Replaces
1628107 20554908
3173759
1075255
1591689
ø91,3x170 M16x2/ø138,5x96
V Arm 095.265
Replaces Suitable for
20556490 FH12 J
NH12
3173291
NH12 BR
1628133
8156991
L: 677,3 mm
Replaces Replaces
1628107 20554908
3173759
1075255
1591689
ø91,3x170 M16x2/ø138,5x96
V Arm 095.486
Replaces Suitable for
1194631 B 10 B
B 10 M
B 12
B 12 M
B9S
L: 773 mm
Replaces Replaces
1598588 20554908
3159435 3173759
1075255
1591689
ø91,5x150 M16x2/ø138,5x96
L: 665 mm
Replaces Replaces
1135080 1598588
3159435
ø52xø91,3x85 ø91,5x150
L: 566 mm
Replaces Replaces
1135080 1598588
3159435
ø52xø91,3x85 ø91,5x150
L: 800 mm
Description 030.038
Rubber Bushing
Min. 60 ShA
Replaces
1614355
ø91,5x150
L: 799 mm
Description 040.570
Repair Kit
Replaces
3093462
ø75xø17/115
L: 620 mm
Replaces Replaces
1135080 1598588
3159435
ø52xø91,3x85 ø91,5x150
L: 591 mm
Replaces Replaces
1135080 1598588
3159435
ø52xø91,3x85 ø91,5x150
L: 496 mm
Description 030.039
Rubber Bushing
Max. 55 ShA
Replaces
1598588
3159435
ø91,5x150
L: 625 mm
Replaces Replaces
1135080 1598588
3159435
ø52xø91,3x85 ø91,5x150
L: 666 mm
Replaces Replaces
1135080 1598588
3159435
ø52xø91,3x85 ø91,5x150
L: 666 mm
030.039 Description
Rubber Bushing
Max. 55 ShA
Replaces
1598588
3159435
ø91,5x150
L: 575 mm
Description 010.674
Repair Kit
Replaces
275988
20808872
ø67xø17/100
L: 666 mm
Description 030.741
Repair Kit
Replaces
20912536
22445502
ø75xø17/115
L: 625 mm
030.741 Description
Repair Kit
Replaces
20912536
22445502
ø75xø17/115
L: 666 mm
030.669 Description
Repair Kit
Replaces
20740700
20753761
24426061
22445499
ø75xø17/130
L: 444 mm
Description 030.741
Repair Kit
Replaces
20912536
22445502
ø75xø17/115
L: 599 mm
Replaces Replaces
20740700 20784709
20753761
24426061
22445499
ø75xø17/130 M30x1,5/ø75x152
L: 599 mm
Replaces Replaces
20740700 20808868
20753761 20784473
24426061 22445494
22445499
ø75xø17/130 M30x1,5/ø75x152
L: 560 mm
L: 449 mm
Description 040.570
Repair Kit
Replaces
3093462
ø75xø17/115
L: 575 mm
Description 030.757
Repair Kit
Replaces
85104224
ø75xø17/115
L: 580 mm
030.669 Description
Repair Kit
Replaces
20740700
20753761
24426061
22445499
ø75xø17/130
L: 510 mm
Replaces Replaces
1135080 1598588
3159435
ø52xø91,3x85 ø91,5x150
L: 510 mm
Description 030.669
Repair Kit
Replaces
20740700
20753761
24426061
22445499
ø75xø17/130
L: 576 mm
Description 030.669
Repair Kit
Replaces
20740700
20753761
24426061
22445499
ø75xø17/130
L: 590 mm
030.038 Description
Rubber Bushing
Min. 60 ShA
Replaces
1614355
ø91,5x150
L: 510 mm
030.038 Description
Rubber Bushing
Min. 60 ShA
Replaces
1614355
ø91,5x150
L: 660 mm
Description 030.528
Repair Kit
Replaces
274070
ø75xø21/130
L: 621 mm
Description 010.674
Repair Kit
Replaces
275988
20808872
ø67xø17/100
L: 666 mm
030.039 Description
Rubber Bushing
Max. 55 ShA
Replaces
1598588
3159435
ø91,5x150
L: 510 mm
030.669 Description
Repair Kit
Replaces
20740700
20753761
24426061
22445499
ø75xø17/130
L: 600 mm
Description 030.757
Repair Kit
Replaces
85104224
ø75xø17/115
L: 660 mm
Description 020.519
Repair Kit
Replaces
274019
273373
4941233
6889509
ø85xø21/130
L: 571 mm
020.519 Description
Repair Kit
Replaces
274019
273373
4941233
6889509
ø85xø21/130
L: 510 mm
030.559 Description
Repair Kit
Replaces
273612
20702095
4881628
ø95xø21/130
L: 515 mm
Description 030.579
Repair Kit
Replaces
20702096
ø85xø21/130
L: 512 mm
Description 030.757
Repair Kit
Replaces
85104224
ø75xø17/115
L: 625 mm
030.757 Description
Repair Kit
Replaces
85104224
ø75xø17/115
L: 564 mm
L:22,312"
A35E FS
A35E
Mounting 16873214 034.226
A35F FS
A35F
A35G FS
A35G
A40E FS
A40E
A40F FS
A40F
ø95xø166x50,5
A35F
A35G
Mounting 16840581 035.041
A40F
A40G
ø166x102/M30x3,5
B 10 B LE
B 10 B
Rubber Bushing 1136891 030.044
B 10 M
B 10 M BR
B 10 R BR
B 12
B 12 BR
ø91,3x150
B7R
B9R
Rubber Bushing 70371217 031.074
ø91,3xø17/115
A35D
A35E
Rubber Bushing 15049695 031.092
11191362
A35E FS
A40D
A40E
A40E FS
T450D
ø110,5xø25/151,5
5350B
5350B 4x4
A25 6x4
A25B
Rubber Bushing 4941208 031.102
5350B 6x4 A25B 4x4
860 A25C
861 A25C 4x4
A20 A30
A20 6x4 A30C
A20C
A25
A25 4x4
ø108xø40x200,7
ø85xø25/152
ø108xø25/152
ø108xø25/152
F10
F12
Repair Kit 274056 030.507
276192
F16
FL10 6889513
FL12
N10
N10 USA
N12
N12 USA
NL10 BR
ø95xø23/152
B 12 B
B 12 M
Repair Kit 3093467 030.613
9523029
B6R
B7R
FH12
FH16
FL6
FM12
FM9
ø75xø17/130
FH Series
FM Series
Repair Kit 20490496 040.503
FM12
FM9
FL6
ø67xø17/115
B 10 B LE
B 10 B
Repair Kit 3097188 020.553
M36x1,5/ø85x248
F10
F12
Repair Kit 273375 020.504
With Bolt
FL10
FL12
FL7
N10 USA
N12 USA
ø90xø23/152
FL6
FL608-615
Repair Kit 3090015 020.535
FLC Series
ø20xø46x60
M20x1,5/ø72x46
M24x1,5/ø90x60
M20x1,5/ø72x46
Dimensions
Sampa No. OEM No. Description Type Applications
A (mm) B (mm)
Type: 3 Type: 4
Dimensions
Sampa No. OEM No. Description Type Applications
A (mm) B (mm)
B10/B12/F12/F16/F7/FE7/FH12/FH16/FL10/FL12/
102.463 965229 Hexagon Bolt With Flange M12x1,75 110 3
FL6/FL7/FM12/FS7/NH12/NL10/NL12
B10/B12/F12/F16/F7/FE7/FH12/FH16/FL10/FL12/
102.463 970983 Hexagon Bolt With Flange M12x1,75 110 3
FL6/FL7/FM12/FS7/NH12/NL10/NL12
B10/B12/F10/F12/F16/FH12/FH16/FH565/FL10/FL6/
102.456 946474 Hexagon Bolt With Flange M12x1,75 120 3
FL616-619/FM10/FM12/FM7/FM9/N10/N12/NH565
B10/B12/F10/F12/F16/FH12/FH16/FH565/FL10/FL6/
102.456 970984 Hexagon Bolt With Flange M12x1,75 120 3
FL616-619/FM10/FM12/FM7/FM9/N10/N12/NH565
B10/B12/B7/B9/F10/F12/F16/FH12/FL608-615/
102.458 979934 Hexagon Bolt With Flange M12x1,75 130 3
FL616-619/FL7/FM12/FS7/N12/NL10/NL12
B10/B12/B7/B9/F10/F12/F16/FH12/FL608-615/
102.458 970985 Hexagon Bolt With Flange M12x1,75 130 3
FL616-619/FL7/FM12/FS7/N12/NL10/NL12
B10/B12/B9/F12/FH12/FL10/FL12/FL6/FL7/FM12/
102.460 978447 Hexagon Bolt With Flange M12x1,75 150 3
FM9/NH12/NL10/NL12
B10/B12/B9/F12/FH12/FL10/FL12/FL6/FL7/FM12/
102.460 970987 Hexagon Bolt With Flange M12x1,75 150 3
FM9/NH12/NL10/NL12
B10/B12/B58/B7/F10/F12/F16/FL10/FL7/N10/N12/
102.462 979935 Hexagon Bolt With Flange M12x1,75 160 3
NL10/NL12
B10/B12/B58/B7/F10/F12/F16/FL10/FL7/N10/N12/
102.462 970988 Hexagon Bolt With Flange M12x1,75 160 3
NL10/NL12
102.512 969222 Hexagon Bolt With Flange M12x1,75 205 3 B10/B12/B7/B9
B10/B12/B7/F10/F12/FH12/FL10/FL6/NH12/NL10/
102.453 975211 Hexagon Bolt With Flange M14x2 65 3
NL12
B6/B7/B9/F10/F12/F16/FH12/FH16/FH565/FL10/FL6/
102.515 968302 Hexagon Bolt With Flange M16x2 70 3
FL7/FM10/FM12/FM7/FS7/N10
B10/B12/F10/F12/F16/FH12/FH16/FL10/FL12/FL6/
102.511 968298 Hexagon Bolt With Flange M16x2 90 3
FM12/FM9/FS7/N10/N12/NH12
B6/B7/F12/F16/FH12/FH16/FL10/FL12/FL6/FL7/M10/
102.216 984868 Hexagon Bolt With Flange M16x2 100 3
FM12/FM7/FM9/N10/N12/NH12
B6/B7/F12/F16/FH12/FH16/FL10/FL12/FL6/FL7/M10/
102.216 968591 Hexagon Bolt With Flange M16x2 100 3
FM12/FM7/FM9/N10/N12/NH12
B10/B12/B7/F10/F12/F16/FH12/FH16/FM10/FM7/
102.243 968592 Hexagon Bolt With Flange M16x2 110 3
FM9/N10/N12/NH12NL10/NL12
B12/B6/B7/F10/F12/F16/FH12/FH16/FL10/FL12/
102.516 968299 Hexagon Bolt With Flange M16x2 160 3
FM12/FM9/N10/N12/NH12/NL10/NL12
102.455 966789 Socket Head Bolt M12x1,75 40 4 F10/F12/F16/FL10/FL12/FL6/FL7/NL10/NL12
sampa.com
Suitable for Scania
V Arm
V Arm 095.491
Replaces Suitable for
1722582 P-, G-, R-, T SERIES TRUCK
1440028
L: 613 mm
Replaces Replaces
1444472 1722584 S
ø70xø19/115 ø85xø25/152
V Arm 095.1117
Replaces Suitable for
1740364 L-, P-, G-, R-, S SERIES TRUCK
P-, G-, R-, T SERIES TRUCK
L: 568 mm
020.524 Description
Repair Kit
Replaces
550806
1104334
639370
ø75xø17/115
L : 522 mm
020.524 Description
Repair Kit
Replaces
550806
1104334
639370
ø75xø17/115
L: 522 mm
Description 040.530
Repair Kit
Replaces
1498131
ø67xø19/115
L: 568 mm
Description 040.503
Repair Kit
Replaces
1853849
550800
ø67xø17/115
L: 596 mm
Replaces Replaces
1372786 1368681
248953 204749
128065
ø121,5xø17/145 ø121,5x77
L: 592 mm
040.570 Description
Repair Kit
Replaces
1517403
550799
ø75xø17/115
L: 568,5 mm
Description 040.530
Repair Kit
Replaces
1498131
ø67xø19/115
L: 580,5 mm
Description 040.591
Repair Kit
Replaces
1498132
ø75xø19/115
L: 629 mm
040.594 Description
Repair Kit
Replaces
2096392
1722753
ø75xø19/115
L: 616,5 mm
040.117 Description
Rubber Bushing
Replaces
1386753
ø92xø17/115
L: 568,5 mm
Description 040.570
Repair Kit
Replaces
1517403
550799
ø75xø17/115
L: 540 mm
Description 020.524
Repair Kit
Replaces
550806
1104334
639370
ø75xø17/115
L: 752 mm
040.684 Description
Repair Kit
Replaces
1783807
ø67xø17/115
L: 568 mm
040.594 Description
Repair Kit
Replaces
2096392
1722753
ø75xø19/115
L: 568,5 mm
Description 040.594
Repair Kit
Replaces
2096392
1722753
ø75xø19/115
L: 592 mm
Description 040.594
Repair Kit
Replaces
2096392
1722753
ø75xø19/115
L: 606 mm
040.594 Description
Repair Kit
Replaces
2096392
1722753
ø75xø19/115
L: 616,5 mm
040.594 Description
Repair Kit
Replaces
2096392
1722753
ø75xø19/115
L: 705 mm
Replaces Replaces
550808 550807
550805
ø67xø17/115 M30x1,5/ø67x136,5
L: 293 mm
L: 522,5 mm
040.594 Description
Repair Kit
Replaces
2096392
1722753
ø75xø19/115
L: 580 mm
020.524 Description
Repair Kit
Replaces
550806
1104334
639370
ø75xø17/115
L: 552 mm
Description 040.684
Repair Kit
Replaces
1783807
ø67xø17/115
L: 522 mm
Description 020.524
Repair Kit
Replaces
550806
1104334
639370
ø75xø17/115
L: 555 mm
040.594 Description
Repair Kit
Replaces
2096392
1722753
ø75xø19/115
L: 525 mm
040.594 Description
Repair Kit
Replaces
2096392
1722753
ø75xø19/115
L: 650 mm
Description 040.573
Repair Kit
Replaces
1435944
ø85xø19/130
L: 640 mm
Description 040.573
Repair Kit
Replaces
1435944
ø85xø19/130
L: 540 mm
040.641 Description
Repair Kit
Replaces
1783020
ø75xø17/115
L: 150 mm
L: 150 mm
L: 610 mm
Description 040.692
Repair Kit
Replaces
2021378
ø85xø21/152
L: 605 mm
040.692 Description
Repair Kit
Replaces
2021378
ø85xø21/152
L: 615 mm
040.692 Description
2021378
Replaces
Repair Kit
ø85xø21/152
L: 650 mm
Description 040.573
Repair Kit
Replaces
1435944
ø85xø19/130
L: 637 mm
Description 040.641
Repair Kit
Replaces
1783020
ø75xø17/115
L: 670 mm
040.573 Description
Repair Kit
Replaces
1435944
ø85xø19/130
L: 568 mm
040.530 Description
Repair Kit
Replaces
1498131
ø67xø19/115
L: 145 mm
Description 010.685
Repair Kit
Replaces
-
ø56xø15/90
ø121,5xø18,5/145
ø98xø25/130
ø85xø19/130
ø67xø17/100
M24x1,5/ø95x72
ø75xø19/115
ø95xø21/152
ø95xø23/152
M39x1,5/ø85x172,5
M22x1,5/ø85x145
M22x1,5/ø95x149
M24x1,5/ø95x70
L-, P-, G-, R-, S SERIES TRUCK Repair Kit 2465189 040.690
ø75x85
Type: 1 Type: 2
Dimensions
Sampa No. OEM No. Description Type Applications
A (mm) B (mm)
P-, G-, R-, T SERIES TRUCK,
101.438 1485733 Bolt M18x2,5 395 1
4 SERIES TRUCK
P-, G-, R-, T SERIES TRUCK,
102.518 814860 Hexagon Head Screw M14x2 45 2
F-, K-, N SERIES BUS
P-, G-, R-, T SERIES TRUCK,
102.518 808361 Hexagon Head Screw M14x2 45 2
F-, K-, N SERIES BUS
P-, G-, R-, T SERIES TRUCK,
102.517 802077 Hexagon Head Screw M16x2 55 2
F-, K-, N SERIES BUS
P-, G-, R-, T SERIES TRUCK,
102.517 802268 Hexagon Head Screw M16x2 55 2
F-, K-, N SERIES BUS
P-, G-, R-, T SERIES TRUCK,
102.154/1 815978 Hexagon Head Screw M16x2 100 2
F-, K-, N SERIES BUS
P-, G-, R-, T SERIES TRUCK,
102.158 802276 Hexagon Head Screw M16x2 110 2
F-, K-, N SERIES BUS
P-, G-, R-, T SERIES TRUCK,
102.244 802277 Hexagon Head Screw M16x2 120 2
F-, K-, N SERIES BUS
P-, G-, R-, T SERIES TRUCK,
102.212 802278 Hexagon Head Screw M16x2 130 2
F-, K-, N SERIES BUS
P-, G-, R-, T SERIES TRUCK,
102.496 802279 Hexagon Head Screw M16x2 140 2
F-, K-, N SERIES BUS
P-, G-, R-, T SERIES TRUCK,
102.493 1408339 Hexagon Head Screw M16x2 200 2
4 SERIES TRUCK
P-, G-, R-, T SERIES TRUCK,
102.491 1486500 Hexagon Head Screw M18x2,5 100 2
F-, K-, N SERIES BUS
P-, G-, R-, T SERIES TRUCK,
102.492 1740275 Hexagon Head Screw M18x2,5 130 2
4 SERIES TRUCK
P-, G-, R-, T SERIES TRUCK,
102.492 815984 Hexagon Head Screw M18x2,5 130 2
4 SERIES TRUCK
P-, G-, R-, T SERIES TRUCK,
102.490 1488091 Hexagon Head Screw M18x2,5 210 2
4 SERIES TRUCK
P-, G-, R-, T SERIES TRUCK,
102.163 1381746 Hexagon Head Screw M20x2,5 110 2
4 SERIES TRUCK
sampa.com
Suitable for Daf
V Arm
V Arm 095.269
Replaces Suitable for
1793877 75CF / 85CF
CF75 / CF75IV
1620437
CF85 / CF85IV
0649819 XF95 / XF105
95XF / 95XF 530
F75 / F85 / F95
F2800 / F3600
TT2100 / N2800
L: 602,7 mm
Replaces Replaces
0696321 0696320
1208071
ø95xø23/152 M24x1,5/ø90x59
V Arm 095.270
Replaces Suitable for
1617096 CF65IV
CF75IV
1368270
CF85IV
1390932 LF45IV
1361651 XF105
0080521
0276875
1793875
L: 609 mm
Replaces Replaces
2009108 1676776
1376729
ø75xø23/152 M24x1,5/ø108x68
095.399 V Arm
L: 608,2 mm
Replaces Replaces
0698724 0696320
ø85xø23/152 M24x1,5/ø90x59
095.499 V Arm
L: 609 mm
Replaces Replaces
1861038 1676776
ø70xø23/152 M24x1,5/ø108x68
V Arm 095.1008
Replaces Suitable for
2001491 CF E6
CF MX-11 E6
1883821
CF MX-13 E6
XF E6
L: 609 mm
Replaces Replaces
1914282 1676776
ø70xø23/130 M24x1,5/ø108x68
L: 606 mm
Description 020.601
Repair Kit
Replaces
1294251 S
ø67xø19/130
L: 611 mm
050.529 Description
Repair Kit
Replaces
1376728
ø75xø21/130
L: 390 mm
Replaces Replaces
1271124 0693778
ø72xø19/130 ø80xø21/152
L: 600 mm
Description 050.560
Repair Kit
Replaces
1243618
ø67xø17/115
L: 600 mm
Description 050.616
Repair Kit
Replaces
1789649
ø75xø21/130
L: 595 mm
030.559 Description
Repair Kit
Replaces
0689761
ø95xø21/130
L: 665 mm
020.524 Description
Repair Kit
Replaces
0689748
ø75xø17/115
L: 590 mm
Description 040.503
Repair Kit
Replaces
1628671
ø67xø17/115
L: 611 mm
Description 051.401
Rubber Bushing
Replaces
2050766
1817809 S
1663207 S
ø70xø21/130
L: 576 mm
020.546 Description
Repair Kit
Replaces
5014765 S
ø75xø19/130
L: 745 mm
L: 665 mm
L: 610 mm
L: 1600 mm
ø90,5x73
M24x1,5/ø108x68
ø90,5xø21/135
F1600
F2100
Repair Kit 0691703 010.575
F2300
F2500
F2700
F2800
F2900 / F3200
F3300 / F3600
ø85xø21/152
SB Series
MB230
Repair Kit 0689749 010.578
ø85xø19/130
SB Series
MBG200
Repair Kit 0067354 010.668
ø75xø19/130
75CF
85CF
Repair Kit 1321936 010.671
CF75
CF75IV
CF85
CF85IV
F75
F85
ø67xø19/130
ø75xø21/130
ø67/ø17
M39x1,5/ø85x172,5
M30x1,5/ø67x136,5
M20x1,5/ø72x46
M20x1,5/ø72x46
M20x1,5/ø72x46
M24x1,5/ø90x59
75CF / 85CF
CF75 / CF75IV
Repair Kit 1208070 050.562
CF85 / CF85IV
XF95 / XF105
95XF / 95XF 530
F75 / F85 / F95
F2800 / F3600
TT2100 / N2800
M24x1,5/ø90x59
Type: 1 Type: 2
Dimensions
Sampa No. OEM No. Description Type Applications
A (mm) B (mm)
0282812 65CF - 75CF - 85CF - 95XF - CF65 - CF75 - CF85 -
102.135 Hexagon Head Screw M20x2,5 90 1
0311049 LF45 - LF55 - XF105 - XF95 - XF95II - YTZ95
65CF - 75CF - 85CF - 95XF - CF65 - CF75 - CF85 -
102.136 0286369 Hexagon Head Screw M20x2,5 120 1
LF45 - LF55 - XF105 - XF95 - XF95II
75CF - 85CF - CF75 - CF75IV - CF85 - CF85II -
102.495 0311034 Hexagon Head Screw M18x2,5 90 1
CF85IV - SB250 - XF105
65CF - 75CF - 85CF - 95XF - CF65 - CF75 - CF85 -
102.551/1 1676426 Hexagon Head Screw M20x2,5 55 1
LF55 - LF55 - XF105 - XF95
0251279 65CF - 75CF - 85CF - 95XF - CF65 - CF75 - CF85 -
104.120 Lock Nut M20x2,5 16 2
1355553 LF55 - LF45 - SB225 - SB250 - TB2175 - XF105 - XF95
sampa.com
Suitable for Iveco
V Arm
V Arm 095.247
Replaces Suitable for
41034479 EUROTECH
EUROSTAR
41042050
E.TECH CURSOR
41028600 EUROMOVER
41028598 E.TRAK CURSOR
STRALIS
41009665
STRAL.2007
41002770 E.STAR CURSOR
8137026 E.TECH CURSOR
L: 665 mm
Replaces Replaces
93161960 93161958
ø75xø21/130 M20x1,5/ø72x46
Description 060.531
Repair Kit
Replaces
93161959
ø16,5x70/144x65
095.351 V Arm
Replaces Replaces
2980884 2968454
ø72xø19/130 M20x1,5/ø72x46
095.390 V Arm
L: 659 mm
Replaces Replaces
93161960 93162239
ø75xø21/130 M16x1,5/ø72x48
V Arm 095.483
Replaces Suitable for
41042093 E.TECH CURSOR
E.STAR CURSOR
500340451
STRALIS
L: 665 mm
Replaces Replaces
93161960 42535781
ø75xø21/130 M20x1,5/ø72x46
V Arm 095.484
Replaces Suitable for
41218620 STRALIS
TRAKKER
41218621
STRAL.2007
STRAL.MY2013
TRAKKER
TRAK.MY2013
L: 665 mm
Replaces Replaces
42567360 42567359
ø75xø21/130 ø85xø25/152
095.485 V Arm
L: 665 mm
Replaces Replaces
42567360 42566700
42569146
ø75xø21/130 ø100xø25/152
095.485/1 V Arm
L: 665 mm
Replaces Replaces
42567360 42566700
ø75xø21/130 ø100xø25/152
V Arm 095.485/2
Replaces Suitable for
41296731 STRALIS
STRAL.2007
41296730
STRAL.MY2013
L: 665 mm
Replaces Replaces
42567360 42566700
ø75xø21/130 ø100xø25/152
L: 583 mm
L: 610 mm
010.576 Description
Repair Kit
Replaces
93192619
42493431
93162288
ø95xø21/152
L: 583 mm
020.501 Description
Repair Kit
With Bolt
Replaces
2980884
ø72xø19/130
L: 594 mm
Description 010.668
Repair Kit
Replaces
93192361
93161637
ø75xø19/130
L: 595 mm
Description 010.671
Repair Kit
Replaces
93163617
ø67xø19/130
L: 610 mm
010.575 Description
Repair Kit
Replaces
93192618
93161720
ø85xø21/152
L: 592 mm
020.546 Description
Replaces
-
L: 582 mm
Description 010.576
Repair Kit
Replaces
93192619
42493431
93162288
ø95xø21/152
L: 585 mm
Description 040.692
Repair Kit
Replaces
5801384823 S
ø85xø21/152
L: 582 mm
010.698 Description
Repair Kit
Replaces
-
ø85xø21/152
L: 594 mm
020.672 Description
Repair Kit
Replaces
41272426 S
ø75xø19/130
L: 455 mm
Description 020.546
Repair Kit
Replaces
500333284
ø75xø19/130
L: 455 mm
Description 020.546
Repair Kit
Replaces
500333284
ø75xø19/130
L: 670 mm
ø85xø19/130
ø85xø21/130
CITYCLASS
EURORIDER
Repair Kit 42535445 020.550
ø67xø15/100
ø67xø17/100
EURORIDER
CRISTALIS
Repair Kit 504001436 040.530
ø67xø19/115
ø85xø19/130
ø75xø21/130
ø67xø17/115
ø67xø19/130
ø85xø21/145
M24x1,5/ø95x72
M20x1,5/ø95x72
M20x1,5/ø72x46
EUROTECH
EUROSTAR
Repair Kit 93161638 060.510
M16x1,5/ø72x48
EUROTECH
EUROSTAR
Repair Kit 93162240 060.532
E.TECH CURSOR
EUROMOVER
E.STAR CURSOR
STRALIS
E.TECH CURSOR
E.TRAK CURSOR
M16x1,5/ø72x48
sampa.com
Suitable for R.V.I.
V Arm
V Arm 095.249
Replaces Suitable for
7420 741 703 C Series
D Wide Series
7422 318 833
KERAX DXI 11 -FAB-34.C/34.F
PREMIUM DXI 7 -FAB-29.B/29.G
PREMIUM -TR-FAB-24.F/25.C
PREMIUM -PR-FAB-24.F/25.C
L: 662,4 mm
Replaces Replaces
7420 547 286 7420 741 710
ø75xø19/115 M20x1,5/ø72x46
V Arm 095.282
Replaces Suitable for
7421 474 441 KERAX DXI 11 -FAB-34.C/34.F
KERAX DXI 13 -FAB-36.D/36.E
7420 829 503
L: 671 mm
Replaces Replaces
7420 840 815 7420 840 820
ø85x21/26x130 M14x1,5/ø90x60
095.368 V Arm
L: 651 mm
Replaces Replaces
7420 864 587 7420 864 583
ø108xø23/165 M14x1,5/ø90x36/50
095.392 V Arm
L: 671 mm
Replaces Replaces
7421 295 230 7420 840 820
ø85xø23/130 M14x1,5/ø90x60
V Arm 095.413/SD
Replaces Suitable for
7422 238 525 C Series
D Wide Series
L: 662 mm
Replaces Replaces
7421 196 270 7422 238 527
ø86xø20/115 M12x1,75/ø75x43
L: 565 mm
010.578 Description
Repair Kit
Replaces
5001 842 823
ø85xø19/130
L: 575 mm
080.543 Description
Repair Kit
With Bolt
Replaces
5001 823 280
ø90xø21x152
L: 575 mm
Description 080.542
Repair Kit
Replaces
5001 842 337
ø85xø21x152
L: 575 mm
Description 080.505
Repair Kit
With Bolt
Replaces
5001 014 345
ø80xø19x145
L: 575 mm
080.504 Description
Repair Kit
Replaces
5000 802 123
5001 831 526
ø85xø19x145
L: 559 mm
080.222 Description
Rubber Bushing
Replaces
5001 829 737
ø72xø17/122
L: 582 mm
Description 080.222
Rubber Bushing
Replaces
5001 829 737
ø72xø17/122
L: 582 mm
Description 080.222
Rubber Bushing
Replaces
5001 829 737
ø72xø17/122
L: 574 mm
Replaces Replaces
5001 842 337 5010 064 794 S
5003 101 582 S
ø85xø21x152 M20x1,5/290/130
L: 586 mm
010.715 Description
Repair Kit
Replaces
5010 094 840 S
ø75xø21/152
L: 654 mm
Description 080.543
Repair Kit
With Bolt
Replaces
5001 823 280
ø90xø21x152
L: 510 mm
Description 030.559
Repair Kit
Replaces
7420 702 095
ø95xø21/130
L: 515 mm
030.579 Description
Repair Kit
Replaces
7420 702 096
ø85xø21/130
L: 512 mm
030.757 Description
Repair Kit
Replaces
7485 104 224
ø75xø17/115
L: 625 mm
Description 030.757
Repair Kit
Replaces
7485 104 224
ø75xø17/115
L: 564 mm
L:22,312"
ø90,5x73
MAXTER 6X4-8X4
KERAX ==> 1999
Rubber Bushing 5010 294 577 080.223
KERAX FAB 33A==>S 2000==>2002
KERAX (FAB 33AA/../../SS)
ø90,5xø21/135
ø75xø19/130
ø67xø15/100
T Series
T High Series
Repair Kit 7420 490 496 040.503
ø67xø17/115
ø85xø19/130
M140/160/200/230
MIDLINER GRANDE-BRETAGNE
Repair Kit 5000 819 365 080.586
5010 104 465
M/S 150/180/210/220/230TI/250
MACK MS200/250/300 1990---> 5000 823 228 S
MACK MS200/250/300 1990--->
ø75xø17x122
ø80xø21/152
ø80xø19/130
M20x1,5/ø72x46
ø90
Dimensions
Sampa No. OEM No. Description Type Applications
A (mm) B (mm)
102.497 5003 001 874 Hexagon Head Screw M16x1,5 100 2 Kerax-Premium-Manager
102.498 7420 920 916 Hexagon Head Screw M18x1,5 120 2 Kerax-Magnum-Manager-Mascott
080.145 5000 715 344 Hexagon Head Screw M18x1,5 270 2 Kerax-Magnum-G/R Series
Premium-Kerax-Magnum-Midliner
102.238 5003 101 582 Hexagon Head Screw M20x1,5 130 2
Midlum-Manager-Maxter-Mack
Kerax-Premium-Magnum-Maxter
102.141 5003 001 990 Hexagon Head Screw M20x1,5 150 2
Manager-Mack-G/R/M Series
102.500 5010 064 794 Hexagon Head Screw M20x1,5 290 2 Kerax-Sisu-Maxter
102.444 7400 955 401 Hexagon Head Screw M20x2,5 180 2 Kerax
102.443 5003 001 649 Hexagon Head Screw M20x2,5 200 2 Kerax-Midliner-R Series
102.461 7400 965 197 Hexagon Bolt With Flange M12x1,75 100 3 D Series
102.463 7400 965 229 Hexagon Bolt With Flange M12x1,75 110 3 C/D/K/T Series
102.463 7400 970 983 Hexagon Bolt With Flange M12x1,75 110 3 C/D/K/T Series
102.515 7400 968 302 Hexagon Bolt With Flange M16x2 70 3 Kerax-Premium-Magnum
102.511 7400 968 298 Hexagon Bolt With Flange M16x2 90 3 C/D Series
sampa.com
Suitable for Solaris
Torque Rod
L: 455 mm
Description 020.558
Repair Kit
Replaces
-
ø85xø21/130
L: 576 mm
Description 020.546
Repair Kit
Replaces
-
ø75xø19/130