Professional Documents
Culture Documents
EVO Bass Bridge Installation Manual
EVO Bass Bridge Installation Manual
EVO Bass Bridge Installation Manual
Please take a few minutes to read the brief installation & adjustment instructions
below.
“ For optimal performance, it is recommended that all EVO Bass Bridge is installed by
a skilled musical instrument builder or technician. “
1. Install your strings by passing each string through the EVO Bass Bridge & the
String Intonation tube.
2. With moderate tension applied to the strings on the String Tuners on your
Bass, adjust the string height with the included Allen wrench key ( 5 )
approximatively, so that the strings are not touching the fretboard.
3. Turn clockwise to lift the string height.
There is a M3x0.5 mm screw ( 6 ) inside the String Adjusting hole.
By turning clockwise the screw ( 6 ), using the included Allen wrench key ( 5 ),
this screw will action, moving the EVO CAM ( 2 )
4. Turn counter clockwise the M3x0.5 mm screw ( 6 ), to lower the string height ,
by using the included Allen wrench key ( 5 ).
5. Turn by hand the Intonation String tube for each string inside the EVO CAM
( approximatively 15 mm / 0.600 inches )
7. Tune your bass with moderate tension until the string tension is not to high in
order to adjust the string height first.
9. Adjust your desired String action height ( see Pos.3 & Pos.4 )
10. Tune your bass after having adjusted your desired string height.
11. Adjust the intonation by using the included String Tube Wrench Key ( 4 ), turn
the fine intonation String Tube ( 1 ) until the desired position is achieved.
13. After having done all adjustment, you can start playing your instrument.
IMPORTANT NOTICE:
• ANY MODIFICATION OR INSTALLATION OF AFTERMARKET COMPONENTS
MAY CAUSE COSMETIC DAMAGE TO YOUR INSTRUMENT!