Professional Documents
Culture Documents
Msds Tesa 60151
Msds Tesa 60151
Schweiz, Zurich:
Centre Suisse d'Information Toxicologique
(Swiss Toxicological Information Centre)
Freiestrasse 16, CH-8032 Zurich
Telephone: +41 44 251 66 66
Emergency telephone: +41 44 251 51 51 (145 from within Switzerland and
Liechtenstein)
Fax: +41 44 252 88 33
E-mail: info@toxi.ch
Web site: http://www.toxi.ch
(Contd. on page 2)
GB
48.1.33
Page 2/9
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2019 Version number 26 Revision: 13.03.2019
(Contd. of page 1)
GHS02 flame
GHS07
GHS02 GHS07
· Signal word Danger
· Hazard-determining components of
labelling: propan-2-ol
· Hazard statements H225 Highly flammable liquid and vapour.
H319 Causes serious eye irritation.
H336 May cause drowsiness or dizziness.
· Precautionary statements P210 Keep away from heat, hot surfaces, sparks, open flames and
other ignition sources. No smoking.
P241 Use explosion-proof [electrical/ventilating/lighting] equipment.
P303+P361+P353 IF ON SKIN (or hair): Take off immediately all contaminated
clothing. Rinse skin with water [or shower].
P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes.
Remove contact lenses, if present and easy to do. Continue
rinsing.
P405 Store locked up.
P501 Dispose of contents/container in accordance with local/regional/
national/international regulations.
· 2.3 Other hazards The preparation contains no elualable organic halogene compounds, which
increases the AOX values
· Results of PBT and vPvB assessment
· PBT: Not classified
· vPvB: Not classified
48.1.33
Page 3/9
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2019 Version number 26 Revision: 13.03.2019
(Contd. of page 2)
· Regulation (EC) No 648/2004 on
detergents / Labelling for contents not applicable
· Additional information For the wording of the listed hazard phrases refer to section 16.
48.1.33
Page 4/9
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2019 Version number 26 Revision: 13.03.2019
(Contd. of page 3)
· Information about protection
against explosions and fires:
Keep ignition sources away - Do not smoke.
· Protection of hands:
Protective gloves.
48.1.33
Page 5/9
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2019 Version number 26 Revision: 13.03.2019
(Contd. of page 4)
· Penetration time of glove material The exact break trough time has to be found out by the manufacturer of the
protective gloves and has to be observed.
· Eye protection: Safety glasses recommended during refilling.
Safety glasses
48.1.33
Page 6/9
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2019 Version number 26 Revision: 13.03.2019
(Contd. of page 5)
(Contd. on page 7)
GB
48.1.33
Page 7/9
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2019 Version number 26 Revision: 13.03.2019
(Contd. of page 6)
Must be specially treated under adherence to official regulations.
· European waste catalogue (recommendation)
07 07 04* other organic solvents, washing liquids and mother liquors
HP 3 Flammable
HP 4 Irritant - skin irritation and eye damage
HP 5 Specific Target Organ Toxicity (STOT)/Aspiration Toxicity
· Additional information about the
European waste catalogue: The assignment of a waste key number according to EC Decision 2000/532/EC in
connection with EU Directive 75/442/EC has to follow specific industry
requirements. The obove mentioned classification is only one possible proposal.
· Uncleaned packagings:
· Recommendation: Disposal according to official regulations.
48.1.33
Page 8/9
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2019 Version number 26 Revision: 13.03.2019
(Contd. of page 7)
· Transport category 2
· Tunnel restriction code D/E
· IMDG
· Limited quantities (LQ) 1L
· Excepted quantities (EQ) Code: E2
Maximum net quantity per inner packaging: 30 ml
Maximum net quantity per outer packaging: 500 ml
· UN "Model Regulation": UN 1219 ISOPROPANOL (ISOPROPYL ALCOHOL), 3, II
· Water hazard class: Water hazard class 1 (Self-assessment): slightly hazardous for water.
· 15.2 Chemical safety assessment: A Chemical Safety Assessment has not been carried out.
48.1.33
Page 9/9
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 13.03.2019 Version number 26 Revision: 13.03.2019
(Contd. of page 8)
PBT: Persistent, Bioaccumulative and Toxic
SVHC: Substances of Very High Concern
vPvB: very Persistent and very Bioaccumulative
Flam. Liq. 2: Flammable liquids – Category 2
Eye Irrit. 2: Serious eye damage/eye irritation – Category 2
STOT SE 3: Specific target organ toxicity (single exposure) – Category 3
· * Data compared to the previous
version altered.
GB
48.1.33